How do I stop my golf cart from smoking?
Start out by carefully removing the valve's screws and taking them out of the engine. Remove the valve with gloved hands to avoid getting stained by excessive grease or oil. Clean off the area where you are installing the valve and put the new valve in place. Tighten it down and your engine should stop smoking.
What would cause a golf cart to smoke?
If your engine is overfilled with oil, the oil can sometimes come up into the valve cover faster than it can drain. This oil then goes into the vent tube back into the carburetor and blows oil into the intake of the carburetor causing your cart to blow smoke.
Why does my golf cart struggle up hills?
A golf cart is designed to carry two golfers and their equipment around the course with less effort than walking. When you're electric golf cart struggles on inclines for a variety of reasons, including weak batteries, incorrect tires, or worn-out motor or wiring, you could be in for a long day.
How can I make my golf cart climb hills better?
An older cart can be upgraded to perform better up hills. Adding larger 20"- 23" all terrain tires will help. 1) Tighten your terminal connections. 2) Clean any corrosion on battery terminals and cables.
What causes a Yamaha golf cart to smoke?
Why is your Yamaha golf cart smoking bad? A Yamaha golf cart may be smoking because the exhaust is plugged with burnt oil that causes back pressure. If it's blowing the oil fill cap off, then oil is clogged up and causing pressure in the crankcase.
How do you clean a golf cart muffler?
How to clean golf cart muffler:First spray the inside of the muffler using the chamber cleaner.After a few minutes, scrub inside the golf cart muffler with the help of a brush.Place a container under the muffler to keep the carbon particles that come out from the golf cart muffler.More items...
Which golf cart is best for hills?
More Terrain Versatility – A gas golf cart does much better with steep hills and rough terrain because it has more horsepower to do tougher tasks. Longer Use – A gas golf cart is going to last much longer on a full tank of gas compared to an electric golf cart on a full battery in almost every case out there.
Can a 36 volt golf cart go up hills?
A golf cart powered by a 36-volt motor would either move too slow or not at all when going up on a hill. It is recommended to use a 48-volt battery for optimum performance as it creates more low-end torque and faster acceleration.
How do I know if my golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How steep can a golf cart path be?
Limit slopes to about 15 percent where practical and avoid steep drop-offs near the paths for safety. Cross fairways if necessary, avoiding prime landing areas.
What is better 36 volt or 48 volt golf cart?
Basically, a 48V system gives you more “pep in your step” and picks up/speeds up a bit faster than a 36V system. Energy Needed/Amps Drawn- A 48V system draws less amps and provides a little more range with all things being equal (cart/passenger payload weight, motor horsepower, etc).
How fast is a 72 volt golf cart?
19 mphE-Z-GO 72-Volt Express S4FrameWelded steel with E-coat & DuraShield powder coatSpeedUp to 19 mph +/- 0.5 mph (Up to 30.6 kph +/- 0.8 kph)SteeringSelf-compensating rack and pinionSuspensionLeaf springs with hydraulic shock absorbersService BrakeRear wheel mechanical self-adjusting drum brakes24 more rows
What causes a golf cart to burn oil?
A club car golf cart with a blown head gasket is the most common cause of the golf cart burning a lot of oil. The presence of accumulated dirt inside the gasket can also cause oil to burn. When a club car golf cart burns excess oil, your fuel expenditure shoots up drastically.
What causes a golf cart motor to backfire?
Engine backfiring occurs when there is an air leak within your golf cart or sometimes when there is too much fuel inside. This can cause the piston to slam against the cylinder head and cause a tapping sound. An essential component of any golf cart is the drive belt.
Why is my electric golf cart sputtering?
If your cart seems to run fine for a few feet, and then it stutters, it is most likely the batteries. If it is not the battery, then check if it is the speed controller or the resistor. If it is the controller, then you will need a replacement. Otherwise, upgrading the resistor can also solve the problem.
How do you adjust the carburetor on a EZ Go golf cart?
2 Cycle engine: The adjustment screw is on the side of the carburetor and is parallel to the ground. You can identify it by the lock nut at the base of the screw. Loosen this and turn the screw all the way into a soft seat, then back it out one and a half (1-1/2) turns.
Why Do Golf Carts Blow Out Smoke?
Your cart shouldn’t blow out a lot of smoke. It should run quite clearly without much smoke if your cart has been serviced regularly and maintained well . Older carts tend to release more smoke than newer ones though.
Why does my golf cart spit?
Golf carts can spit and sputter for several reasons, but mainly due to worn out spark plugs or dirty filters inside the fuel system. There might be something wrong with the fuel system of your cart. You could be having a spit and sputter problem because the filter, pump and injectors in your golf cart are very dirty.
Why Does a Golf Cart Sputter and Die?
If your cart sputters and dies, it might be because your spark plug is faulty. If your cart starts and runs for awhile but then sputters then dies, try replacing your spark plug. If you’re lucky that’ll instantly solve your problem. If not, you might have a failing ignition coil.
Why does my carburetor spit gas?
Problems with the timing chain in your cart might also be making your carburetor spit gas. If you have a timing belt that jumps, it’s probably causing your gas spitting problems. Jumping belts are more common when you have plastic camshaft timing gears rather than metal timing gears. Lastly, bad reeds can lead to gas spitting.
How to fix gas spitting from valve cover?
Here’s what you can do to fix gas spitting from the valve cover. Replace the needle in the carburetor or replace the whole carburetor. The other thing that’s likely to cause gas to spit from the valve cover of your cart is your carburetor float being stuck open. This is simple enough to fix.
What to do if your golf cart is spitting gas?
Lastly, if your golf cart is spitting gas, you may need to replace your air box. A relatively common problem is getting replacements that aren’t the stock air box for your cart. Something that most people don’t know or forget about is that if you’re using aftermarket filters, you absolutely must reset your carburetor.
Why is my oil more than full?
Your oil will probably be more than full because of this: the oil has been diluted with fuel! Here’s what you can do to fix gas spitting from the valve cover.
Why is your Yamaha golf cart smoking bad?
A Yamaha golf cart may be smoking because the exhaust is plugged with burnt oil that causes back pressure. If it’s blowing the oil fill cap off, then oil is clogged up and causing pressure in the crankcase.
Why is your Yamaha gas golf cart blowing white smoke?
White smoke is caused by oil burning or “too full” oil condition in your engine. “Too full” oil condition is what happens when there’s too much fuel in your oil.
Why is your golf cart burning oil?
Your golf cart is burning oil because it has too much oil in the airbox. If your oil is overfilled, then drain it out and put in exactly one quart of oil into your cart engine.
Why is your Yamaha G1 smoking?
Your Yamaha G1 is more than likely smoking because your muffler is clogged with oil and soot. The muffler becomes like this over time, especially if your car is only used in short bursts.
Why is your Yamaha G16 burning oil?
Your Yamaha G16 is burning oil because it has fuel in the oil. The first thing you should try to fix the burning oil problem is replace the old oil in your cart with exactly one quart of high quality oil. Hopefully this immediately fixes your problem.
Why is my G16 oil overfilled?
Your oil being overfull might be because you lifted your cart which causes your oil dipstick reading to be off (the full mark is incorrect). This causes you to overfill your oil. If your oil smells like gas and is too overfull then gas will get dumped into the crankcase of your G16 and cause smoking.
How to fix a muffler on a golf cart?
There are two ways to fix this problem; the first is to run your cart long and hard for 30 minutes to an hour and then let the cart cool off. The second is to remove your muffler and burn it out on a bonfire to clear up all the oil and soot in it.
Claude Kayser
An expert who has finished #1 on the weekly Top 10 Fixya Experts Leaderboard.
Basic EZGO Golf Cart Problems And How To Fix -
Apr 30, 2010 - Electric E-Z-Go Golf Carts are becoming more popular every day ..... I have a ezgo carryall gas golfcart. it has began to pour smoke from rear.
ARISTON frontloader WMG829 Replace inside lock unit Hi, I am hoping someone can help me. I have a Ariston front loader and I need to replace the inter lock unit. I have searched YouTube but I am finding they have the screws on the outside to release. Mine does not have a screw. I checked on the inside with a mirror and couldn't find one. Anyone have any tips? I also tried to change the door handle with lock and the whole glass piece fell and smashed to pieces... I have another one on order. This time I ordered the whole door, it includes the handle.
ARISTON frontloader WMG829 Replace inside lock unit Hi, I am hoping someone can help me. I have a Ariston front loader and I need to replace the inter lock unit. I have searched YouTube but I am finding they have the screws on the outside to release. Mine does not have a screw. I checked on the inside with a mirror and couldn't find one.
What does blue smoke mean on a carburetor?
Well blue smoke means you are burning oil. Bad rings and oil getting into combustion chamber could be a possibility. However I would first drain your oil and put fresh oil (I am guessing it is SAE 30) in it. Make sure it is a the proper level. To much may be your issue. If the problem is still there I would take off your carburetor and clean it completely, and lightly oil your gaskets. If it still has an issue it may be a bigger issue. Could you post the model number so I can help further?
What does blue smoke mean?
Well blue smoke means you are burning oil. Bad rings and oil getting into combustion chamber could be a possibility. However I would first drain your oil and put fresh oil (I am guessing it is SAE 30) in it. Make sure it is a the proper level. To much may be your issue.
Why does my golf cart go slow?
Our assessment of why does my electric golf cart goes slow uphill has yielded several answers. While battery problems tend to be the most common reason for slow speeds uphill. The size of your tires, speed, wire corrosion, and brake solenoid damage are also possible causes for your cart’s slow speeds. I recommend checking your batteries ...
Why is my electric golf cart slow?
Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart’s slow speed.
Why are my cart batteries so slow?
As your batteries age, they are no longer able to hold a charge like they previously did. They, therefore, struggle to generate sufficient power under load. I have heard cart owners complain of slow speeds on inclines, even though their batteries had the proper voltage.
What factors affect your speed uphill?
The size of your cart tires is another factor that may be impacting your speed uphill. The larger your tires are, the more work your cart needs to do to get uphill.
Why do old batteries go uphill?
Older batteries tend to lose the ability to deliver sufficient torque to your cart, which would impact its performance going uphill.
Can mud affect a cart's speed?
That impacts the ability of your cart to navigate slopes and may even struggle on flat terrain. The performance of your cart’s sensor can become impaired from mud build-up, which cover s the sensors and blocks their ability to determine speed. Cleaning the mud off the sensors should see it back up and running.
Is it worse to put your foot on the gas pedal?
There is nothing worse than putting your foot on the gas pedal, only to get no response. At first, we push down on the accelerator with more force, but we soon realize that all power has been lost, and our carts are now crawling at a snail’s pace.
