What are the most common problems with golf carts?
One of the common problems found in golf carts is a constant whining noise during the ride. This noise is usually found coming from the rear end and would seem to originate from one of the parts at that end.
What happens if you hit a golf cart on the fairway?
The water can damage the cart, and the cart can damage the mounds and bunkers. Many golf courses do not allow golf carts on the fairway of a par-3 hole. Making sharp turns, or speeding along in the cart and coming to a sudden stop, can damage the turf grass.
How close to the Golf Course can you drive a golf cart?
Steering Clear Keep your cart away from tee boxes, and about 30 feet away from the greens. Signs near the green might say, “No carts beyond this point,” or arrows might point to the cart path. Do not drive close to water hazards, grassy mounds or bunkers.
Why is my golf cart so bumpy?
Too high a pressure makes the cart ride bumpy while too low pressure causes the cart to drag. Rotating the tires occasionally for uniform use is a good idea. To confirm if your shocks need to be changed, get on to the bumper of the cart and push it down three to four times continuously.
What causes a golf cart to jerk while driving?
A Club Car golf cart jerking from the front end of the golf cart occurs due to poor quality of tires. If the tires are worn out or loose, the golf car can start jerking. The uneven height of your front tires can also cause jerking.
How can I make my golf cart ride smoother?
How to Make a Golf Cart Ride SmootherCorrect Tire Pressure. ... Replace Worn Out Shocks and Struts. ... Check the Fluid and Filter. ... Replace the Clutch. ... Flat Spot in Tire. ... Tire Damaged or Out of Line. ... Worn Out Suspension Bushings. ... Check Your Lift/Tire Combo.More items...
Why does my golf cart make a loud noise?
Golf Cart Making Whining Noise The whining noise could be because of damaged motor bearings or an indication of needing fluids/oil. As a solution, you can check the fluid levels throughout your cart and change them if the fluid is too thick or the fluid level is too low, to make sure the whining noise goes away.
How do I know if my golf cart shocks are bad?
Is your cart extra noisy when going over bumps or even when driving around gently? Chances are your suspension parts are getting old. Golf cart shocks, struts, coil-over suspension and leaf spring parts fade out over time due to use and age.
Why does my golf cart ride so rough?
Your golf cart ride can be rough because of tire problems, suspension problems or issues with the transmission. Tire Problem: Incorrect air pressure and wrongly aligned tires are two key tire-related problems that can trigger rough golf cart rides.
What PSI should my golf cart tires be at?
15 to 25 pounds per square inchThese tires typically use anywhere from 15 to 25 pounds per square inch (PSI), with the average being 20 to 22 PSI. For golf carts driven off-road or on rougher terrain, it's not uncommon to under-inflate tires to gain additional traction. However, under-inflated tires wear down prematurely.
How can I make my golf cart quieter?
Here's a quick answer: The easiest ways to make a gas golf cart quieter are by adding a muffler or more insulation to the cart's body. Before making any modifications to your golf cart, be sure that any noises aren't a sign of mechanical issues.
Why do golf cart batteries boil over?
The reason behind the bubbling or gurgling sound of the golf cart batteries is the gases that are present in the batteries. When charging your golf cart batteries, the amperage exceeds the level of the natural absorption rate, which could later cause the battery to overheat.
Are gas powered golf carts loud?
A gas golf cart is loud because of its engine. Generally, the larger the engine, the more noise that it will make. Some people who have smaller carts and just take them on smooth rides/flat surfaces will not notice much golf cart noise.
What does bad shocks sound like?
Unusual noises – When shocks and struts are worn out you may hear a clunking or knocking sound. This sound is caused by metal-to-metal contact when the shock or strut bottoms out when hitting a bump. In addition, these noises could be a result in worn shock or strut mounting components.
How can you tell if your suspension is bad?
Signs of a Worn SuspensionClunking Noises When Hitting a Bump. ... Bumpy Ride. ... Hovering Front End. ... Irregular Tire Wear. ... Noticeable Vibrations While Driving. ... Erratic Braking. ... Fluid Leakage. ... Irregular Tire Wear.
How long do electric golf cart motors last?
However, their durability is the same as that of an electric vehicle, which is nice for those who are interested in gasoline or diesel golf carts. That said, some manufacturers claim that the average golf cart will last 30-40 years if the engine is properly maintained, repaired, or even replaced.
Are electric golf carts loud?
Almost No Noise – A huge selling point to consumers and people on a golf course about electric golf carts is that they are silent. You really can't hear an electric golf cart in most cases unless you have clubs banging together in the back.
Why is my ezgo beeping?
An EZGO golf cart can keep beeping because of a faulty battery, overcharging of batteries, or a faulty controller. After the engine becomes active and the accelerator is pressed, it generates a sound like something I clicked. It is here to note that one can hear this sound only when someone presses the accelerator.
Why does my EZGO RXV ride rough?
Why an EZGO RXV rides rough. Your EZGO RXV often tends to ride rough because of the following reasons. Too much air in the tires. If the golf cart tires have too much air and uneven pressure, the rides may be rough. You can consider checking this out and releasing the excess air or pressure.
How to make a golf cart ride smooth?
You can make your golf cart ride smooth by checking for the above-mentioned problems in the cart and attending to them. Correct tire pressure. Check if the front and back tires have the correct and even pressure according to specifications. They may need different pressures based on the conditions and seasons.
Why is my golf cart so rough?
Your golf cart ride can be rough because of tire problems, suspension problems or issues with the transmission. Tire Problem. Suspension Problem. Transmission Problem. Tire Problem: Incorrect air pressure and wrongly aligned tires are two key tire-related problems that can trigger rough golf cart rides.
How much pressure should I put on my golf cart tires?
Check the pressure of all the tires in the cart. If it’s above 30 PSI, you might want to release some pressure so that it’s in the range of 20 to 22 PSI per tire. On a golf course, 8 to 10 PSI is more than enough. You can also check out with a tire shop to get the tires balanced.
How to get smoother ride on Yamaha G16?
You can get a smooth ride from your Yamaha G16 golf cart by ensuring the following. Ensure that there is no air leak in the gaskets between the intake and the carburetor as well as the spacer. You can pull out the airbox and check for a damaged gasket or spacer.
What causes a golf cart to bounce?
Check if your golf cart is fitted with heavy-duty leaves. These are often known to cause bounce. Replacing them with stock leaves or removing a couple of them should solve the problem.
Why is my car bumpy?
Check the pressure on all tires and release some pressure if you find that it’s too high as this can cause bumpy rides.
Why Do Golf Carts Bounce when Driving?
Have you been experiencing some bounce in your golf cart while driving? Well, in most cases, it could be due to the condition of the roads. However, there may be some issues with your cart which could be causing these bounces, that may require attention.
Why are my front tires bouncy?
If you do not use your cart much and it stays idle for weeks at a time, it could cause the tires to go out of shape due to the weight of the cart.
How to fix a cart that is wobbling at high speed?
Consider replacing the springs with harder ones . This could help solve the issue of the cart wobbling at high speed.
What is a MCOR?
Every cart has something called an MCOR (Motor Controller Output Regulator). It is part of the pedal assembly and can be found under the foot pedal. By removing the floor mat, you can access the foot pedal assembly unit.
How to get a bouncy cart back to its original shape?
You can try driving the cart for a few miles to warm up the tires. This will cause them to get back to their original shape and help resolve the issue of the bouncy cart.
Why is my cart bouncing?
If the cart is still bouncing, you will know that the problem is not with the tire. Instead, the issue could be due to a bent wheel. In this case, you will just have to get the wheel replaced. If both these cases do not seem to be the cause, then it could be due to the axle or the wheel bearing.
Why does my clutch jerk?
Well, the issue could be related to the clutch. The primary clutch weights could be broken, which might be causing the jerks. It would be a good idea to get your clutch checked to help resolve the problem. Another cause of this issue could be the accumulation of dirt or dust particles in the clutch.
How to stop a transaxle from whining?
Check if the transaxle has run dry of lube and apply some synthetic lube or 30w oil for lubrication if needed to eliminate the whining noise.
Why does my club car DS make a clunk?
The front-end clunking noise in a Club Car DS is due to worn out bushings under the spring and spindle, loose nuts on the spindle, a damaged rubber bumper or a cracked front leaf spring plate.
What to check for on a motor shaft?
Check the motor shaft for a worn out or defective plastic bushing and do a replacement if required.
Why does my Club Car DS make a popping noise when turning the steering wheel?
The Club Car DS makes a popping noise when turning the steering wheel due to loose components in the front suspension, a cracked upper clevis, a worn out steering, missing bushings or lack of grease.
Why does my gas golf cart make a squealing noise?
The gas golf cart tends to make a squealing noise due to a loose or worn out starter/generator belt, a loose drive and/or alternator belt or a dusty clutch. Loose or worn out starter/generator belt. Loose drive and/or alternator belt. Dusty clutch.
Why does my clutch make a noise?
Clutch making noise (Club Car DS) The clutch in the Club Car DS makes a noise because of a worn out clutch, damaged clutch belt, shaft or buttons or low oil level in the rear end. Worn out clutch. Damaged clutch belt, shaft or buttons. Low oil level in the rear end.
Where are the input shaft bearings on a 2006 Club Car?
The input shaft bearings are usually located inside the differential in a 2006 Club Car. You might want to check on the shafts too.
What does the first beep sound on a cart mean?
The manual will have the list of beeps and their respective fault codes. The first beep sound will indicate the performance factor.
How to check battery water level in golf cart?
How to Check Battery Water Levels in a Golf Cart. Check if the voltages in both the batteries are at the designated levels. Also, if the water in the batteries has dried up, it could cause this issue. Check for the electrolyte and water levels in the batteries. Make sure that you are not overcharging or undercharging your batteries as these could ...
Why does my cart have a loose solenoid?
If the connections from the solenoid have become loose or if there is some other loose contact, the cart might behave in this manner. It can also be caused by a faulty motor or a faulty key switch.
What is a MCOR?
Every cart has a Motor Controller Output Regulator called MCOR. Any issue with the MCOR can easily affect your cart. This MCOR helps in converting your foot motion on the pedal into the necessary impulses to the motor controller unit. Check whether the MCOR has any issues or is broken.
What causes a cart engine to die?
If your cart engine dies suddenly, it may be the carburetor causing the issue. Read the following steps to fix it:
Why does my golf cart keep powering off?
If the cart starts powering off after a new installation, then you will know that the issue is caused due to errors with the installation.
Why does my golf cart cut out?
Another reason why golf carts can cut out is due to problems with the battery voltage or water levels.
Why do golf carts need to be shared?
Walking or sharing a cart goes a long way toward reducing cart traffic and improving turf health. This helps courses conserve resources and provide better playing conditions for everyone.
Why do golf courses use ropes?
Golf facilities use ropes, stakes, signs and many other traffic control measures to minimize the negative impacts of cart use; but ultimately, they depend on golfers to be mindful of where and how they drive.
How does cart traffic affect golf?
Many factors influence how cart traffic affects a golf course. Certain grasses are more vulnerable to traffic injury and may require special cart policies. Areas with heavy soils and poor drainage face a greater risk of compaction and other traffic issues. Even the time of year plays a role. When grasses are growing slowly, they are more vulnerable to the cumulative effects of cart traffic. For all these reasons, cart policies vary from course to course, hole to hole and even day to day.
Why are golf carts important?
Golf carts can improve access and generate revenue, but they can also have negative impacts on turf health and playing conditions. (Green Section) Golf carts play an important role at many golf facilities. They provide a revenue source and increase accessibility, allowing golfers who might not otherwise be able to walk the course to enjoy playing.
Why are grasses more vulnerable to cart traffic?
Even the time of year plays a role. When grasses are growing slowly , they are more vulnerable to the cumulative effects of cart traffic. For all these reasons, cart policies vary from course to course, hole to hole and even day to day. 2. Wet conditions and cart traffic do not mix.
What is the USGA?
The USGA promotes and conserves the true spirit of the game of golf as embodied in its ancient and honorable traditions. It acts in the best interests of the game for the continued enjoyment of those who love and play it. The USGA: Celebrating 125 Years. Design Philosophy From Female Golf Course Architects. GIVING.
How long does it take for a tire to heal on a lawn?
Cart traffic during hot and dry weather can also cause turf damage. The tire marks that appear on dry or heat-stressed turf can take weeks to heal.
What are the symptoms of a bad solenoid on a golf cart?
In addition, the spring that pulls the pinion back to its resting position could wear down leaving the starter engaged continuously. (Starters are supposed to get the flywheel moving, then back out of position – disengage.)
What does it mean when a golf cart solenoid goes bad?
Technically, in fact, a solenoid is a shape – a shape in which the length of something coiled is longer than the diameter of the coils. In engine starters, this refers to the smaller motor ...
Why does my golf cart make clicking sounds?
On a gas golf cart, the most common symptom is the starter failing to engage – so the engine doesn’t turn over – while all you hear a series of very futile clicking sounds.
How to check ohms of a cable?
Once you’ve disconnected the cables safely – using your multimeter – use the voltmeter on the ohms setting and touch each large terminal with the probes with the key turned off. You should get a zero reading.
Why does my solenoid wear out?
Like any switch that relies on wiring, the solenoid could also just wear out due to overheating. This might cause it to fail to retrieve the pinion gear.
What does a solenoid do when you turn the ignition?
Step by step, it looks like this: When you turn the ignition key, a small amount of electricity goes to the solenoid. The solenoid uses that small amount of juice to close two heavy-duty contacts that allows a large jolt of electricity to pass through the starter. The solenoid also sends a pinion gear forward, which is the device ...
Why do starter contacts wear out?
Secondly, the contacts could begin to wear out from overheating or exposure to high levels of current. This needs to be fixed right away if possible, because this causes continuous use of the starter. If not caught in time, the solenoid and the starter will both need replacement.
How to keep golf cart off the grass?
On days when the golf course requires cart path only, you must keep the golf cart on the designated path and off the grass. Drive to a point where you are even with the ball, and walk to the ball. You may want to take several golf clubs with you, since you won’t be able to see the conditions near the ball from the cart. Course officials invoke this rule to protect the fairway grass, and may be in effect for all or some of the holes.
What is the 90 degree rule?
The 90-Degree Rule. Players should stay on the cart path whenever possible to protect the fairway turf. On some days, especially when the course is wet, you may be asked to follow the 90-degree rule. Under this rule, carts are allowed on the fairway, but they must maintain a 90-degree angle from the cart path.
What does the sign near the green mean?
Signs near the green might say, “No carts beyond this point,” or arrows might point to the cart path.
Can you damage grass in a cart?
Making sharp turns, or speeding along in the cart and coming to a sudden stop, can damage the turf grass. The same goes for driving through wet or muddy areas, or grass with standing water. Keep the cart away from naturalized areas to protect the grasses and wildlife.
Do you drive a golf cart around the green before putting?
As a courtesy to the group behind you, it is customary to drive the golf cart around the back of the green before putting, or at least before entering scores. This speeds play, since the next group will not be forced to wait while you clear the area.
Where is Sharon Penn?
Sharon Penn is a writer based in South Florida. A professional writer since 1981, she has created numerous materials for a Princeton advertising agency. Her articles have appeared in "Golf Journal" and on industry blogs.
Do you drive a cart in front of other players?
For your safety and for the safety of your passenger, do not drive the cart in front of other players in your group or another group. As a courtesy, do not drive forward or back up when a player is addressing the ball.
What joint should a thumb splint be used for?
Any splint used should include the thumb to help support the basilar joint. Doctor Visit: A diagnosis will likely entail the doctor loading the thumb’s basilar joint and briefly “grinding” it — you may feel the discomfort and mechanical symptoms that accompany joint irregularity.
Why does my thumb feel weakened?
Your hand may feel weakened as discomfort can lead to protecting the thumb from tasks (e.g., opening jar s) in which grip power is necessary and potentially painful. Self-Care: There is a wide range of nonsurgical managements—ice, heat, splints and judicious use of over-the-counter anti-inflammatories.
What is the thumb in golf?
The thumb is remarkable, and we ask much of it. Gripping a golf club throughout the swing means positioning the thumb at multiple points in space , and that demands great flexibility. This flexibility is provided by two hinge joints and the very agile basilar joint — where the thumb plugs into your wrist — plus great strength and stability.
How to close a modal window?
This is a modal window. This modal can be closed by pressing the Escape key or activating the close button.
How long did Jason Day miss the 2014 Masters?
Here’s how to deal with one of the most dreaded injuries in golf. In the early part of the 2014 season, Jason Day missed six weeks with a thumb injury, which he aggravated at that year’s Masters tournament. Arnold Palmer is famous for, among other things, his iconic “thumbs up” to adoring galleries. (Sorry, Phil.)
What is Arnold Palmer famous for?
Arnold Palmer is famous for, among other things, his iconic “thumbs up” to adoring galleries. (Sorry, Phil.) I was lucky enough to call Arnold a good friend; in 2006, we launched the Arnold Palmer Sports Health Center. He had an abiding interest in keeping people healthy and participating in the game he loved.
Can golfers get arthritis?
This balancing act can create a problem that manifests as friction at the basilar joint—aka arthritis. Almost all golfers will eventually get a little degenerative “wear and tear” arthritis at the thumb joint.
