A faulty Forward/Reverse switch can cause a Club Car golf cart to move in reverse but not forward. Replace the entire switch and the contacts if they are burnt. The cart moving only in the reverse and not in the forward position is peculiar and there are only a few areas that need to be checked.
Full Answer
Why won’t my golf cart move in forward or reverse?
There might be several reasons why a golf cart won’t move in forward or reverse. The most likely reason is incorrect wiring or a faulty accelerator. If you’re mechanically experienced, you can attempt to use the tips below to fix the problem yourself. I have outlined the most likely causes and steps to fix this below:
Where is the reverse switch on a golf cart?
The reverse switch is found below the driver’s seat, and can be activated by pulling the handle left or right. Once pulled, the golf cart will start moving in reverse.
How do you stop a golf cart from backfiring?
One simple way to stop the golf cart from backfiring is to use good quality fuel. Once this is done, ensure that the throttle plate is closed by adjusting the accelerator cable at the plate. The following are some ways EZGO TXT golf cart owners have stopped backfiring in their carts.
What does the forward micro switch do on a golf cart?
The forward micro switch is what engages the activation circuit. So, when getting the cart in reverse, make sure that it closes. If the cart continues in the forward direction, then the issue is with the micro switch and not the controller that needs to be replaced.
How do you fix a reverse golf cart?
One possible cause of a cart not moving forward or in reverse is because of the way the wires are hooked in reverse. To fix this, you should switch the position of both the wires that are leading to the motor. If the golf cart is not rolling across freely, there might be an issue with the brakes.
Can you pull a golf cart in neutral?
Golf cart models that are equipped without a handle-style brake have an unlock procedure that is listed on the bottom of the controller cover. Or try to use the Tow-Run switch in tow, then key in neutral. If the batteries are completely dead, then removing the brake is the only option.
Why won't my golf cart go forward or reverse?
The problem could be with either the Run/Tow switch or Forward/Reverse switch or both. Check the switches to ensure that they aren't stuck midway. If they are, getting them released should help. However, if they show signs of wear and tear, you must get them replaced.
What makes golf carts go forward?
The next most common problem you're likely to experience with your golf cart is a malfunctioning controller. Controllers for direction come in two varieties – forward and reverse. As a result, a cart that will go forward but not reverse may have a broken controller for the reverse that needs to be fixed or repaired.
Can you haul a golf cart backwards?
Towing Backwards Due to the fact many golf cart windshields are of the snap on variety, you must NEVER tow the golf cart in your truck or trailer with the front of the golf cart facing rearward.
What happens if you tow a golf cart not in tow mode?
If you do not flip the switch to “TOW” prior to pulling the vehicle, you can cause serious and even catastrophic damage to the controller, the motor, or both. The most common component to sustain damage by towing the cart without flipping the switch is the controller.
How do you reset an electric golf cart?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
What do you do if your golf cart won't go?
Press the button and put your cart back together before hooking it up to charge. In many cases, this will solve the problem. If it doesn't, try removing the motor and testing it with a separate, fully charged battery. If nothing happens, the motor is probably burned out.
Where is the reset button on a Club Car golf cart?
Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.
How does a golf cart forward reverse switch work?
0:139:43Golf Cart Forward and Reverse Switch Direction Selector Tutorial - YouTubeYouTubeStart of suggested clipEnd of suggested clipThat is brand new it simply cables connect to the bright copper colored contacts. And the switchMoreThat is brand new it simply cables connect to the bright copper colored contacts. And the switch rotates through a hand action and that changes the polarity.
How do I reset my EZGO golf cart?
Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button. Push the button to reset the motor.
How do you put a club car in neutral?
0:151:07PRO TIP - Putting a Club Car DS Golf cart (Gas) into Maintenance ModeYouTubeStart of suggested clipEnd of suggested clipOkay here's a quick tip anytime you're working on a club car especially on the on the club card DXMoreOkay here's a quick tip anytime you're working on a club car especially on the on the club card DX there's a little yellow switch. Right here see when this is in neutral you push the gas.
How do you tow a gas golf cart?
0:582:017F Towing - YouTubeYouTubeStart of suggested clipEnd of suggested clipUnder the seat into the toe position. This will allow the rear wheels to freely roll. Once allMoreUnder the seat into the toe position. This will allow the rear wheels to freely roll. Once all vehicles are connected disengage the parking brake of each vehicle that is being towed.
How do you push a gas golf cart?
How do you jump start a gas golf cart?Lift the seat and connect the jumper cables as you normally would.Carefully close the seat on the cables and climb aboard.Apply brake fully w/left foot.Put the cart in gear.Start the cart w/right foot.More items...•
How do you start a club car in neutral?
1:0914:141993 Club Car DS Golf Cart, Neutral Bypass Cold Start Hack, Trail Romp!YouTubeStart of suggested clipEnd of suggested clipBut the front one. If you step on the gas now you can actually uh turn it over this is kind of theMoreBut the front one. If you step on the gas now you can actually uh turn it over this is kind of the neutral bypass switch and by lifting it up i'm bypassing the neutral.
How does reverse work on a golf cart?
How does reverse work on a golf cart? Golf carts have a button or lever that allows you to switch between forward and reverse gears. The reverse switch is found below the driver’s seat, and can be activated by pulling the handle left or right. Once pulled, the golf cart will start moving in reverse.
Why won't my golf cart go forward?
There might be several reasons why a golf cart won’t move in forward or reverse. The most likely reason is incorrect wiring or a faulty accelerator.
Why is my cart not moving forward?
One possible cause of a cart not moving forward or in reverse is because of the way the wires are hooked in reverse. To fix this, you should switch the position of both the wires that are leading to the motor.
Why is my golf cart not moving in reverse?
The reverse switch can be the reason for preventing the golf cart from moving in reverse. It might have lost contact, and the connection would have been disrupted.
What is a forward micro switch?
The forward micro switch is what engages the activation circuit. So, when getting the cart in reverse, make sure that it closes. If the cart continues in the forward direction, then the issue is with the micro switch and not the controller that needs to be replaced.
Why is my golf cart not rolling?
If the golf cart is not rolling across freely, there might be an issue with the brakes. Inspect the brakes and rear ends and check out for any seizing up. There can also be an issue with the controller. Make sure that you have new batteries inserted in the golf cart and that they are not drained.
How to make sure your golf cart is running?
Since the golf cart does not run on motor machinery so you can get it going with a gentle turn of your wrist, you must not wait for any sounds to be sure that your golf cart is running, just ensure that ignition is turned to ‘on’ position.
How to stop a golf cart from backfiring?
Once this is done, ensure that the throttle plate is closed by adjusting the accelerator cable at the plate.
Why does my golf cart backfire?
A golf cart backfires through the carburetor because of an open throttle plate. The accelerator cable at the plate is out of adjustment and in turn, stops the plate from closing when the microswitch makes contact with the ignition. The accelerator cable moves through the throttle plate before the click but the plate cannot do so.
How to close throttle plate?
If you have a rod system between the carburetor and accelerator pedal instead of accelerator cables, adjust the length of the accelerator rod that is just in front of the carburetor. This will help to close the throttle plate completely.
How to tighten accelerator cable?
If the accelerator cable passing through the throttle plate is held in position using a cable nut, loosen the nut and press the throttle plate till it’s closed. Once the plate is closed, tighten the nut once again. Ensure that the accelerator cable spring remains pressed against the throttle plate.
What to do if your carburetor is cracked?
Replace the plastic manifold spacer between the carburetor and head if it’s cracked. Also, replace a leaky exhaust pipe or gasket.
What to do if throttle cable spring is missing?
If the spring over the throttle cable between the cable stop and cable arm is missing or has lost its tension, do a replacement. Follow up with a recalibration of the governor.
How to stop a Yamaha G29 from backfiring?
The steps below can stop a Yamaha G16 golf cart from backfiring. If the governor is set to a high speed or RPM, adjusting it to a lower setting may work. Check the oil quality and levels. Do an oil change if it’s poor quality oil or fill oil to the required level.
Golf Cart
Support for gas-powered and electric golf carts, sometimes referred to as golf cars or club cars after the Club Car Golf Cart brand.
2 Answers
Look at the motor. On one end of the motor (the side closest to the gearbox) the studs will be labeled S1 and S2 (for a Series cart) or F1 and F2 (for a sepex cart). Take those two cables off and swap them and your problem should be rectified
When did golf carts evolve?
Club Car Golf carts have evolved many times since 1975, and although the basic electrical design has stayed close to the same, there are small differences. These differences are important when troubleshooting your cart.
What is a golf cart?
Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf...
How to adjust a golf cart?
Adjustment is made by loosening the nut or screw, pressing the throttle closed, and then retightening the nut. Some golf carts may not have accelerator cables but instead will have a series of rods between the gas pedal and the carburetor.
Why does my golf cart backfire?
Golf Cart Backfires Because Fuel Mixture Is Too Rich. Always check the air and fuel ratio to make sure your engine is not receiving too rich of a fuel mixture. The following adjustments are an example of most carburetors, but you should look up the proper number of screw turns your model requires.
What happens when the throttle cable is out of adjustment?
When the throttle cable is out of adjustment, the throttle plate never completely closes, allowing unburned gasoline to accumulate in the exhaust system before the spark plug fires. Here are a few tips for adjusting your golf cart engine to keep it from backfiring.
Why is my throttle plate not closing?
If none of these accelerator cable adjustments solve the problem, then the throttle plate may not be closing all the way due to an obstruction or internal mechanism being bent. Unfortunately, the only way to find out if this is true is to remove the carburetor and inspect it.
What is the ignition system on a golf cart?
Older golf carts used a set of points and a condenser to produce the spark needed to run the engine, but the more modern carts have a solid-state ignition system . The solid-state system utilizes an internal magnetic pickup device inside the engine that sends an electrical signal down the line to the igniter.
Why is my piston red?
If you find that there is a buildup of coke on the top of your piston be sure and use a blunt tool to scrape it off because the piston material is very soft and can scratch or gouge easily. A scratch or gouge would glow red at the edges and cause just as much of an ignition point as the original issue would have and would defeat the purpose of de-coking.
What is a golf cart?
Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf... Continue Reading.
Why does my golf cart stop moving?
This Golf cart is very temperamental, and even things like over-tightening a stud can make it stop moving. Check the F/R switch stud for overtightening. If it is over-tightened, the contact will not connect with the switch. Adjust this, and your golf cart will start working.
Why won't my TXT golf cart charge?
A TXT golf cart may not charge because of loose or broken wires, a dirty charging port, a blown fuse, or problems with the auxiliary contact.
Why is my cart sluggish?
If your cart has a dirty carburetor, it may be sluggish during acceleration. You can prevent these issues by regularly cleaning the carburetor.
Why are my golf cart drum brakes stuck?
Drum brakes can get stuck due to rust and corrosion. To remove your E-Z-Go golf cart drum brakes, follow these steps.
What to do if your charger is defective?
If your charger is defective, replace it with a DPI charger.
What does it mean when your cart has blue exhaust?
If you have blue exhaust, something is wrong with your cart. It can be a sign of a problem with your engine oil. Address this problem immediately, as it could lead to an engine fire.
When was the RXV golf cart made?
The company first made RXV golf carts in 2008. You can find their serial in the following spots.
