Briefly, you have to perk up the cart on a hydraulic lift, remove the tires, remove the front axles, install the new tie rods, and use the new locknuts to secure it in place. Install the lowering block by removing the support plate below the leaf springs and fix the new spring plate with a new set of fasteners.
Full Answer
How to fix loose steering on an EZGO golf cart?
How to Fix Loose Steering on an EZGO Golf Cart? Start with the steering box and the tie rod. If the problem is with the tie rods, then loosen them and turn the steering... Reattach the tie rod after turning the wheel to each side equally. If the steering is still loose, move on to the... Ensure the ...
How do you adjust the speed on an EZ GO golf cart?
Tighten the governor spring located in the engine of most golf carts to adjust your cart's top speed. 90% of EZ Go Carts have simple springs which limit the speed of the engine. To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly.
What psi should the tires be on an EZGO cart?
The standard recommended pressure of an EZGO cart’s tires ranges from 18 to 22 PSI. Be sure to inspect your tires regularly, too, and replace them as necessary. If your cart is driving slower than usual or making strange noises “down there,” it could very well just be a sign of low tire pressure.
What size struts do I need for an EZGO golf cart?
Specifically designed for Older Ezgo Golf Carts utilizing a 3/4 Inch front roof strut and 1 Inch rear struts – See Details This is a common topic among RV people that pull their golf cart with them on their travels or the race car guys traveling around the country from event to event.
How do I lower my EZ Go golf cart?
3:155:56When installing your lower spring plate make sure that the bends. At the edge of the spring plateMoreWhen installing your lower spring plate make sure that the bends. At the edge of the spring plate are pointing down and away from your leaf.
How much does it cost to lower a golf cart?
A lift kit for a golf cart is usually priced around $250. If you install the kit yourself, then your expenses will end there. If you need to hire someone to lift your cart, on average, this will cost you about $75.00 per hour. Lifting a golf cart is a job that will take a few hours.
How do you lower the top of a golf cart?
3:0210:18You got to remember to cut at a 45 degree angle. Back that way the roof will fold back. So all yourMoreYou got to remember to cut at a 45 degree angle. Back that way the roof will fold back. So all your cuts when you decide your when you determine your cut.
How do you drop a golf cart?
0:422:44In this area. Here that's one club length from my nearest point of relief. And no closer to the holeMoreIn this area. Here that's one club length from my nearest point of relief. And no closer to the hole. So I would hold my arm out shoulder length and just let the ball drop.
Can you lower a lifted golf cart?
The lowering of the golf cart involves inserting a 2-inch or 2.5-inch tubular block along with the right-sized 'U' rings and nuts. The lowering is done in both the rear and front of the cart. You can also choose to lower the front alone.
Is a lifted golf cart better?
Higher Speed A lifted golf car usually means larger tires. These tires offer a higher level of speed than regular tires do. The difference in speed varies from a few miles per hour to 20 mph. Speed may not be necessarily beneficial from a safety standpoint, but it allows you to drive faster.
How do you raise the roof on a golf cart?
2:146:14For 20 bucks i bought two pieces of eighth inch angle angle arm two pieces. And if you look on thatMoreFor 20 bucks i bought two pieces of eighth inch angle angle arm two pieces. And if you look on that one you'll see one that's not completely welded yet. So our solution was you take the two inches.
Will a lifted golf cart fit in a toy hauler?
As long as the cart is not too wide, it should be fine to fit in your toy hauler. However, if the cart has mirrors on both sides of the front wheels, it might not fit inside.
How tall is a golf cart with a roof?
Dimensions of EZ-Go Golf CartModel NameLengthHeight (W/ roof)Freedom RXV ELiTE94.5 in68.5 inFreedom TXT Gas93 in67.5 inFreedom TXT Electric93 in67.5 inEZ-Go Express111.8 in76.8 in5 more rows•Nov 6, 2020
How do you get a free drop in golf?
Free relief is allowed when the ball is in the general area and there is interference by an abnormal course condition. The nearest point of complete relief should be identified and a ball must be dropped in and come to rest in the relief area.
Do you get a free drop from a cart path?
The good news for you is there's no penalty for taking a drop from the cart path. USGA Rules note that a golfer is entitled to free relief from a cart path if the ball comes to rest upon the path or the golfer's swing or stance is inhibited by the path.
How do you find the nearest point of relief?
1:032:26We need to measure that out use your driver it's the longest Club in the bag. But you must take yourMoreWe need to measure that out use your driver it's the longest Club in the bag. But you must take your head cover. Off. We can't go near the hole. Mark that point. And we're gonna drop.
Videos
Here are a few videos for the DIY-ers out there looking to save a few bucks and who don’t care so much about the finished look just need to be able to lower the golf cart top to make it fit somewhere. Checkout this YouTube video to learn more.
Easy to follow
Pete got a member of his office staff to try the kit – here’s what they said:
Added extras
If you are looking for a affordable solution to add some music to your golf cart? Checkout Pete’s new golf cart top mounting Bluetooth stereo systems. Models specifically for the Club Car Onward and Precedent, Ezgo Rxv and the Yamaha Drive. Pete’s Golf Carts has all the cool accessories for your golf cart.
How to adjust EZ Go cart governor?
To adjust an EZ Go Cart Governor engine, start by removing the seat so that you can access the engine. Once the seat is off, remove the screws from the black plastic cover at the rear of the seat and then set the cover aside.
How to make a golf cart go faster?
Loosen the small nut and tighten the larger nut. The more you tighten the larger nut, the faster your cart will go. Start slowly, only tightening the nut a quarter turn to start. You can over-stress the engine if you try to run it too quickly, and it will skip and potentially burn out if you are too eager.
How to get a cart to move faster?
1. Remove the seat and plastic covering over the engine. Sometimes you'll need to remove screws while some models have seats that pop right out. Expose the engine so that you can get to work adjusting the motor. If you don't have a central governor spring, you can still get your cart to move a little faster.
How fast can a golf cart go?
Adjusting the governor can make your golf cart go 5–10 mph (8 .0–16.1 km/h) faster. If you do this to an E-Z-GO golf cart, you might be able to go from 15 mph (24 km/h) to 22 mph (35 km/h). It will only take about 5 minutes to do it. Steps.
How many screws are in a golf cart engine?
There should be five screws in most models. The engine is in the front of golf carts, underneath this panel. Take off the plastic cover and set it aside with the seats. ...
How to change the speed of a car?
Locate your clutch pedal and line. The clutch is the pedal (sometimes a handle near your knee) that you use to put the car into reverse or change speeds. You can adjust the clutch to send more gas to your engine, moving you faster. ...
How to raise the top speed of a golf cart?
To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly. If you cannot find this spring, you likely have a newer model that is more difficult to adjust, though this is rare. Lift up the seat. Remove the seat cousins, which hide the engine.
How to increase speed of EZ Go golf cart?
One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.
Do golf buggies have a carburetor?
Many older models have gas powered engines with a throttle and carburetor linkage. Aside from using the accelerator pedal to go slower or faster, there is a variety of options to adjust the speed of these great golf buggies.
What is an EZGO golf cart?
Your EZGO golf cart is probably a more integral part of your life than you realize. If you live in a residential neighborhood or gated community, chances are that you use your golf cart for a wide variety of purposes beyond simply golfing―to take a trip to the nearby grocery store, to drive a mile or two to the country club or tennis courts down the road, to act as a makeshift hunting vehicle during hunting season, or even to fetch your mail in rainy or snowy weather.
What is the recommended tire pressure for an EZGO cart?
The standard recommended pressure of an EZGO cart’s tires ranges from 18 to 22 PSI. Be sure to inspect your tires regularly, too, and replace them as necessary. If your cart is driving slower than usual or making strange noises “down there,” it could very well just be a sign of low tire pressure.
What does the Ezgo manual say about battery replacement?
The EZGO manual says that, “First, a battery that performs poorly and is outside of the manufacturer’s specification should be identified in order to replace it under the terms of the manufacturer’s warranty.”. This means that every manufacturer retains its own unique requirements, specs, and timelines.
Why is it important to keep a golf cart in good shape?
Therefore, it is very important to keep your golf cart in great shape at all times, and learning how to troubleshoot can mean the difference between diagnosing and quickly fixing problems, or having your cart break down.
How many cycles does a golf cart battery take?
Your golf cart’s battery needs to mature completely before it can operate at its maximum levels. This can take as many as 100 full charge cycles, so be patient if the brand new golf cart you just purchased isn’t quite living up to its battery expectations.
Why is my golf cart foot pedal so smooth?
If you are having issues with the smoothness of your foot pedal, it may simply be due to the air quality of your surroundings and should eventually fix itself. If your golf cart is a few months or years old, the stickiness may be due to constant pressure.
What happens if the voltage is not equal to the voltage on a solenoid?
If it is not equal, then the solenoid has a wiring problem. oYou should also put the positive probe on the opposite post of the solenoid and read the voltage there. The voltage should have three or more volts below the battery’s own reading. If not, then you should get the resistor replaced as soon as possible.
Why does my EZGO golf cart have a loose steering wheel?
EZGO golf carts can experience loose steering because of loose tie rods or worn out steering wheel brushes and spindles. EZGO Golf Carts negotiate with uneven terrain, and loosening of the steering wheel is natural over time. Most cases arise when the cart is faced with a hard surface. The bearing slops and tie rods may have gotten loose.
Why is my 1996 EZGO TXT steering loose?
With your 1996 EZGO TXT model, a loose steering problem can arise from tie rods and worn out or free steering linkages. It may not be significant at lower speeds, but definitely unsafe at a higher pace. Either way, here are the main points you should focus on maintenance –
How to fix a steering wheel that is loose?
Start with the steering box and the tie rod. If the problem is with the tie rods, then loosen them and turn the steering wheel to either side by an equal degree and recenter it. Reattach the tie rod after turning the wheel to each side equally. If the steering is still loose, move on to the steering box.
Why does my golf cart turn left and right?
This happens when the wheel turns the cart excessively to either left or right with the steering. Golf courses are uneven or hard terrain, and the steering wheel can get off-centered or loose when dealing with it. Inspect the steering wheel periodically and adjust whenever necessary, using the right tools.
What is a ball socket on a steering wheel?
Ask someone to move the steering wheel in any direction while you inspect the joints, called ball sockets, which have a bolt attached to the spindle while turning the wheel. Finally, if the problem persists, you might have a worn out or loose kingpin that needs tightening or replacement.
Does a 1998 Ezgo have a steering wheel?
1998 Electric EZGO Golf Carts usually have a front-mounted steering wheel. If your electric TXT model is having a lot of play with the steering wheel, you need to start inspecting the bushings.
Why your EZ GO Golf Cart Runs Slower than Normal?
When you’re EZ Go RXV or TXT golf cart starts running slow, it is usually because of a faulty speed sensor or battery issues. I have compiled a couple of these reasons below. They include the following:
How to Boost the Speed of Your Electric EZ Go Golf Cart
There are several methods for you to make your EZ Go electric golf cart go faster. I have detailed these methods in this section.
Conclusion
Having a faster golf cart can get you from point A to B a lot quicker. Whether you want to upgrade your cart from stock, or just fix the speed you have lost due to faulty batteries or add on parts, this is something that can easily be done.
