Golf-FAQ.com

how to tune a golf cart

by Brent Kemmer MD Published 3 years ago Updated 2 years ago
image

Part of a video titled How to Tune Up Your Gas Golf Cart - YouTube
1:06
8:02
Your oil plug and then you're also going to need a socket to remove your spark plug. If you want toMoreYour oil plug and then you're also going to need a socket to remove your spark plug. If you want to mention here that. This here is a an oil filter wrench they come in a few different.

What is included in a golf cart tune up?

Tuning up a Club Car golf cart requires checking the air flow of the engine, making sure that the fuel is as clean as possible, fixing any spark plug problems, and then testing the results. This process also requires you to gather up a handful of tools that will make tuning up your golf cart much smoother.

How can I make my golf cart faster?

6 Ways You Can Make a Golf Cart Faster
  1. Add More Torque to Your Golf Cart.
  2. Upgrade Your Golf Cart's Motor.
  3. Improve the High-Speed Controller of the Cart.
  4. Add Better Golf Cart Tires.
  5. Use a Higher Powered Golf Cart Battery.
  6. Watch the Weight in Your Golf Cart.
May 18, 2021

How can I make my golf cart sound better?

As mentioned, the 2 best ways to make your golf cart quieter are adding insulation and a muffler.
...
Also, read how to quiet leaf blowers.
  1. Add insulation to your golf cart. ...
  2. Install a new muffler on your golf cart. ...
  3. Opt for sound dampening.

How do you adjust the carburetor on a golf cart?

Find the pilot adjustment screw on the edge of your carburetor. Pay attention to this screw – it should be a sharp point and not flat. Carefully remove this screw and then carefully screw it back. Turn this screw out one and one-half turns to adjust it properly.

Is 30 mph fast for a golf cart?

Depending on how far you want to go on a full charge, you might want a 40mph or a 30mph golf cart. At top speed, most golf carts do around 14mph. However, with the advent of street legal golf carts and modifications, it is possible to go 35mph and above.Oct 4, 2021

Why is my gas golf cart running slow?

Low Battery

Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
Jul 14, 2021

Why is my golf cart so loud?

A gas golf cart is loud because of its engine. Generally, the larger the engine, the more noise that it will make. Some people who have smaller carts and just take them on smooth rides/flat surfaces will not notice much golf cart noise.

What is the quietest golf cart?

Quietech EFI™
Quietech EFI™

Drive2 QuieTech EFI boasts the lowest decibel output of any gas car and features the industry's first-ever Independent Rear Suspension on a golf car. This unprecedented combination ensures your players experience a luxuriously quiet ride.

Do electric golf carts make noise?

Golf Cart Making Beeping Noise

The beeping noise in the golf cart is because the battery is not fully charged, low battery voltage, or because the rear end fluid needs changing. The beeping noise may come during a regular drive, but most people hear it when the cart is being reversed.
Apr 9, 2021

Why does my golf cart only run with the choke on?

Cart Runs Only When Choke is On

This is normally due to a blockage in the fuel line. Another cause is the accumulation of dirt or other debris in the carburetor. To fix this issue, check for any blockages in the fuel line and other engine components.
Dec 2, 2021

How do I adjust my EZ GO carburetor?

2 Cycle engine: The adjustment screw is on the side of the carburetor and is parallel to the ground. You can identify it by the lock nut at the base of the screw. Loosen this and turn the screw all the way into a soft seat, then back it out one and a half (1-1/2) turns.Feb 25, 2021

How do you adjust the governor on a Club Car gas golf cart?

If you find this rod, then your governor can be easily adjusted by accessing the cart's inner workings. Simply adjust the cable coming from this metal protrusion, turning the nut counterclockwise to make the cable longer, effectively adjusting the cart's governance to increase the overall speed.

What is a golf cart?

Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf... link to Club Car DS Wiring Diagrams 1981 To 2002.

How to remove seat from a swivel cart?

Begin by raising the seat upon its hinges and lifting the cushion out of the hinge brackets. These hinges allow removal of the seat by sliding the double-eared tab out of the hinge slot . I missed this feature when I got the cart and didn’t realize I could remove the seat quickly and not have to hold it up with my elbow while I worked.

How to set air mix and throttle screw?

To set the air mix and Throttle screw, we need to use the Torx T15 and remove 2 screws holding the cover that hides the adjustments. After removing the screws, pick up the right edge of the cover and pivot it over and off.

How to tell if fuel is old?

If you have one of the clear plastic filters, you can check the color of the fuel inside it to ensure the gasoline has not gotten too old and turned to a “shellac” condition, usually indicated by a darker amber color rather than a light clear color…c’mon, we all know what gasoline is SUPPOSED to look like. If it gets too old, it not only loses its combustibility but becomes thick and hard to pass through the filter and carburetor jets. Note the position of the filter with the tapered end and the flat end. The fuel flow on this filter goes from tapered to flat end…Don’t get this reversed!

How to start a car when it's cold?

Start It Up. After you have all of the safety measures in place, reach in and press the accelerator with your hand and the engine will begin to turn over. If the engine is still cold, you may need to use your other hand and press the choke button until it fires off.

Can you start a motor without the cart taking off?

When the microswitch is engaged in the “pressed” position, and the lever is in the “Neutral” position, you can start the engine without the cart taking off. It would be safest to chock the wheels to prevent an accidental runaway should you bump the lever while running the engine.

What is a golf cart?

Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf... link to Club Car DS Wiring Diagrams 1981 To 2002.

How to remove fuel filter from car?

The fuel tank is located on the driver’s side of the vehicle and the filter can be removed with a pair of pliers. Squeeze the spring clip and slide it further up the rubber fuel line, then pull the filter free. Note the direction of flow to prevent installing the filter backward.

How to remove spark plug from engine?

Locate the spark plug (s) on the top of the engine and remove the cable, exposing the top of the plug. Use a spark plug socket (13/16″) and ratchet to remove the spark plug and inspect the ceramic insulator.

How to remove gas filler hatch?

Put the vehicle in neutral and open the seat cowling pulling up on the lever in the gas filler hatch. Remove the 5 screws from the front and rear of the cowling and lift out.

What is a golf cart?

Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf... link to Club Car DS Wiring Diagrams 1981 To 2002.

How to remove valve cover bolts?

Remove the valve cover bolts in the pattern shown using a 10mm socket wrench and carefully pry off the cover, retaining the six spacer sleeves and the gasket. Set these aside and inspect the rocker arm assembly. Turn the engine by hand to point the cam lobe (D) down on the first rocker you are checking.

How to remove fuel filter from fuel pump?

To remove the filter, disconnect the hose from the fuel pump by using a pair of pliers to squeeze the clamp ends together and sliding the expanded clamp further down the line. Raise the hose up and allow any excess fuel to drain back into the fuel tank.

Where is the second filter on a carburetor?

Return the filter to the gas line and secure it with the clamps. Sometimes there is a second filter located underneath the carburetor facing the front of the cart. Check to see if you have one and make sure it is also clear of deposits.

Can you tune up an Ezgo golf cart?

All of these adjustments can be made on your EzGo Golf Cart without spending anything more than your time, BUT if any of the components are damaged, such as the gaskets, plugs or if the filters are too far gone to blow the dirt out of them, it is time to open the old wallet. Amazon carries these tune-up kits, and all you have to do is identify which kit matches your cart. Good Luck and happy cruising!

How to adjust carburetor on golf cart?

In most cases, you’ll need to adjust the jet pilot screw, perform a valve clearance adjustment and then clean the carburetor.

How to replace carburetor float?

Remove the carburetor and turn it upside down. Remove the nut that is used to secure the bowl on. Check the float for a puncture as this prevents the activation of the fuel cut-off needle valve. Replace the float if there is a puncture. Check for dirt accumulation in the needle valve.

Why does an EFI carb require more maintenance than an EFI?

The carb requires more maintenance than an EFI because of the cleaning and rebuilding of the carburetor involved.

Why does my carburetor flood on my golf cart?

The reason why a carburetor floods on a golf cart is usually due to a faulty fuel pump. The pump must be repaired or replaced accordingly. Seek professional assistance if required. This is usually due to the proximity of the fuel line to an exhaust manifold, a radiator hose or a heat source.

Where is the main jet on a 2 cycle engine?

The main jet in the carburetor diagram of a 4-cycle engine is located below the carburetor while the pilot jet is present on top of it. The needle valve and float pin are also housed under the carburetor.

How to adjust valve clearance?

Do a valve clearance adjustment starting with the cold valve. The valves can be adjusted using a flat screwdriver, a feeler gauge and a 10mm wrench. The two inner exhaust valves and the outer intake valves must have a clearance of 0.004 mm.

How to remove cable from carburetor?

Remove the cable from the carburetor and cover its sheath opening using duct tape. To do this, make a small funnel with the tape and ensure that the wire sticks out from its middle. Loosen the nut that fixes the cable on to the mount housed on the motor just before its entry into the carburetor.

What is a golf cart?

Golf carts are an efficient and economical mode of transportation on the golf course and around neighborhood communities. While most older model carts use gasoline operated engines, newer carts are battery-operated, providing a quieter and eco-friendlier ride.

How fast can a golf cart go?

If your objective is to make your cart road-worthy, changing the voltage of the battery is an effective way to achieve this. Most golf carts can attain speeds of up to 12 mph, which is perfect for leisurely rides around the golf course, but is too slow when traveling on neighborhood roads. Many communities require carts to travel at speeds of 20 mph, and the average cart with a 36-volt battery is unable to obtain that speed.

What is the center of a golf cart?

As you can see, the speed controller is the center of your golf cart, and most of the other modern day electric vehicles.

What is the most important part of a golf cart?

Even though the speed controller is probably one of the most important parts on your golf cart, not many people understand how they work or what they do. In this guide, we breakdown the speed controller so you have a complete understanding of their functions, and hopefully come out with the knowledge to make an educated decision on the type ...

How many volts does a golf cart need?

You’ll find that most vehicles in this category run with 24 to 36 Volt battery packs.

When upgrading your golf cart controller, do you suggest working with manufacturers that have spent the time building controllers for your specific

When upgrading your controller for your golf cart, we suggest working with manufacturers that have spent the time building controllers for your specific brand.

What to do instead of AC motor?

Instead of using your useless AC motor, or your full power DC motor, consider installing a speed controller.

Can you change the settings on a speed controller?

If you have a computer or a handheld programmer, then changing the settings on your speed controller is super easy.

Can you run a golf cart without a speed controller?

If your golf cart is running an AC or Brushless DC motor , you won’t be going anywhere without a speed controller. In these specific types of motors, electrical signals fire back and forth which reverse in direction at different times. This must stay consistent, and has to be timed precisely with the motors rotation.

image
A B C D E F G H I J K L M N O P Q R S T U V W X Y Z 1 2 3 4 5 6 7 8 9