how to winterize your golf cart

How to store your electric golf cart for the winter?

Oct 25, 2017 · How to Winterize a Golf Cart Thoroughly clean the golf cart with soap and water as well as a degreaser or other recommended cleaning products to... Inspect the brakes. Check the cart for damage or other issues like loose nuts, bolts and screws. Make any necessary... Verify that the tires are ...

How to quiet a golf cart?

May 17, 2021 · Loosen, but do not remove the carburetor drain screw and drain any fuel remaining in bowl into an approved container. Then pour the fuel from the container into the vehicle’s fuel tank and replace and secure the tank cap. Tighten the carburetor drain screw. Disconnect the fuel vent line from tank vent nipple.

How to properly drive a golf cart?

How to Store Electric Golf Carts in the Winter. The Battery. The most important part of an electric golf cart is the battery. Once you have found electric golf carts for sale and made your purchase, ... Check the Battery Cables. Your battery cables should be clean, tightly connected to …

How to wire a switch on a golf cart?

Wash thoroughly with copious amounts of water, standing a few feet back to avoid any acid splash. Wearing a pair of goggles may be a good idea. Water from a garden hose, or even a commercial high pressure washer, will not hurt the electrical components of the car long as you don’t beat the high pressure on any of them for a long period of time.

What do you do with golf cart batteries in the winter?

Keep them in a cool area and stay away from areas that are near heat sources such as radiators or heaters, since hot temperatures accelerate battery self-discharge. In addition, al- ways avoid areas where freezing temperatures are expected during the storage pe- riod.

Should I take my golf cart batteries out for the winter?

One of the most common mistakes during winter months is storing golf car batteries in a discharged state. A discharged battery in extremely cold temperatures will allow the electrolyte to freeze, causing it to expand. Electrolyte expansion can crack the battery case, causing a leak or complete battery failure.Nov 18, 2015

How do you store an electric golf cart in the winter?

You should store your electric golf in a covered dry area, away from any water exposure. A golf cart storage shed would be the best place, but if you don't have a small storage building with a door, make sure you place it under a shelter, and away from where the elements can get to it.Feb 7, 2022

Can you leave a golf cart outside in the winter?

Golf carts can be stored outside for shorter and even longer periods. But one thing comes under consideration while keeping them outside and without any protection, i.e., they can quickly wear out. Golf carts left outside for weeks can cause severe exterior and surface damage and even sometimes become immovable.

Should I leave my electric golf cart plugged in all winter?

Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.

Will water in golf cart batteries freeze?

If you have a golf cart battery that has not been charged sitting in your garage, it will freeze at around 20 degrees Fahrenheit. As many people in cold climates know, this is not all that cold.

How to protect a car from rolling?

To protect the engine, remove the spark plug and pour 1/2 ounce of SAE 10 weight oil into the engine through the spark plug hole. Rotate the crankshaft by hand several times, and then install the spark plug. Do not engage the park brake, but secure the car from rolling.

Why should the tow/run switch be placed in the tow position?

If the chargers are not going to be used to maintain batteries, the Tow/Run switch should be placed in the TOW position and the batteries disconnected after a full charge to prevent any parasitic loss during storage.

What happens when the battery light is off in tow mode?

When in Tow mode, the amber battery warning light will not illuminate. Do not attempt to use the battery light as an indication of battery state while in storage. If AC power is off for 7 days or longer, the OBC will not function or charge the vehicle again until it has been restarted.

What happens if you don't store your car properly?

WARNING: Failure to store a vehicle properly during extended storage periods can result in battery and/or engine damage and render the vehicle inoperative. To prepare a vehicle for winter storage, the following steps outline the procedure that should be followed.

Do you need to charge a battery before off season?

Batteries should be fully charged prior to cars going into off-season storage. Ensure electrolyte level is at the proper level. Only check electrolyte level on a fully charged battery. If electrolyte level is below the top of the plates, refer to the Battery Care section of the Owner’s Manual. Check all electrical wiring ...

Step 1: Thoroughly Clean your Golf Cart

When it comes time to store your golf cart, be sure that it is clean. Use soap, water, degreaser, and other cleaning products as needed to wash away dried mud, sand, grime, and dirt on the golf cart.

Step 2: Winterizing your Golf Cart

If your cart is gas, drain gasoline from all plumbing and parts from the carburetor to the fuel tank. Fuel that is left to sit in the cart over the winter can cause gunk to form in small parts of the carburetor or the fuel pump. If your golf cart has a shut-off valve, make sure it is in the "off" position.

Step 3: Finishing Touches

Disconnect battery cables to prevent any unnecessary electrical problems from occurring while in storage. If the cart will be checked on periodically, leave the batteries connected and hook the cart up to a maintainer. Inflate tires to the proper pressure before storing to maintain the shape of the tires when it is not driven.

What is the 'Run/Tow' switch on a golf car?

If your golf car is an electric RXV, make sure the 'Run/Tow' switch is set to the 'Run/Storage' position. Remember, if it's left in the 'Tow" position, it will continue to drain the batteries over time.

Do golf cart batteries self discharge?

Before leaving your golf cart, ensure that the battery is clean, fully charged, and has been disconnected from any source of electrical drain. Batteries will continue to self-discharge, even during periods where they are not used or are being stored away. If you don't disconnect your battery's wires, you may find yourself with a golf cart battery ...

Can you put away a golf cart in winter?

If you're the type to put away your golf cart or ATV for winter storage, there are a few steps you'll need to take to ensure that your battery stays in peak condition, even if you're not heading out on the course or into the woods during the colder months. We've spoken before about winterizing your ATV, but we haven't really taken a close look ...

When to prep a golf cart for winter?

Prepping The Cart (End Of Fall) During the end of fall season is when you will want to wind up your use of your electric golf cart. The leaves are dropping, the temperature is falling, and you can feel the end is near. Fall is a critical time to start preparing the storage of golf cart for the coming winter months ahead.

When to start preparing golf cart storage?

Fall is a critical time to start preparing the storage of golf cart for the coming winter months ahead. A small amount of cleaning and maintenance is required in order for your cart to survive being locked up in the freezing winter conditions.

What is the best way to clean a battery?

A clean cloth, warm water and baking soda is perfect to clean the battery. The baking soda will neutralize any acid corrosion found.

What is the run/tow switch on a cart?

If the Run/Tow switch is found on your model of cart, it’s very important that you set it to the Run/Storage switch instead. Keeping your cart stored and set to Run/Tow is a great way to drain your battery completely!

How much pressure should I put on my tires?

Your tires will need to inflated between 15-25 PSI, but check your owners manual for the correct amount of pressure. Alternatively, check the side of your tires, and you can probably find the correct PSI number written on them. You’ll want the tires inflated as high as allowable, in order to protect your wheels.

Can you store an electric golf cart in the cold?

There comes a time each year when mother nature deems your electric golf cart unusable. The wet weather turns your otherwise enjoyable ride, into an off road journey into the unknown! When the weather turns cold, it’s time to store your golf cart in a safe place.

Can a golf cart rust in the winter?

Winters especially in the US, can reach extremely cold temperatures. If not careful, moisture from the cooler weather can cause havoc on your golf cart. The moisture from rain, ice and snow will exacerbate the amount of rusting if the issue isn’t taken care of beforehand.