Why is my golf cart jerking forward and reverse?
Consider using a stock belt on the clutch if your golf cart has a severe-duty belt as this can sometimes cause a jerking action. Your Club Car golf cart jerks in forward and reverse due to a sticky drive clutch or a high gear solenoid problem.
Why is my golf cart clicking but not moving?
A Club Car golf cart can start clicking but not move, due to dust accumulating inside the battery ports. Opening the battery ports and checking whether there is any dust accumulation can tell you if this is the case. Cleaning it thoroughly with a cloth can resolve the problem.
Why does my club car DS click but not move?
Reasons why a Club Car DS Clicks but won’t move A Club Car golf cart can start clicking but not move, due to dust accumulating inside the battery ports. Opening the battery ports and checking whether there is any dust accumulation can tell you if this is the case. Cleaning it thoroughly with a cloth can resolve the problem.
How to fix jerky acceleration on a club car golf cart?
One way to fix the jerky acceleration on a Club Car golf cart is to check if the battery charge is dropping and the battery is nearly dead under load. A load test will help you determine this. If recharging the batteries doesn’t help, getting a new battery or new batteries fitted should work.
Why is my golf cart making a clicking noise?
Golf Cart Making Clicking Noise Typically, a clicking noise on a golf cart suggests that wheels drums may be touching the sides of the vehicle. You may also hear a click sound if your car has lost any bolts that are wiggling in place as you ride your cart.
What causes a golf cart to surge?
A golf cart can be surging due to insufficient fuel levels, damaged motor brushes or a vacuum leak. The brushes in the motor are damaged or worn out. The MCOR is malfunctioning or a mismatch between the motor and controller results in torque bumps.
Why does my electric golf cart stutter?
If your cart seems to run fine for a few feet, and then it stutters, it is most likely the batteries. If it is not the battery, then check if it is the speed controller or the resistor. If it is the controller, then you will need a replacement. Otherwise, upgrading the resistor can also solve the problem.
How do I know if my golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
Where is the speed sensor located on a Club Car golf cart?
The speed sensor in a Club Car Precedent golf cart is located on the back of the motor. To remove the sensor, unplug the cables behind the motor. You can use a 5/16-inch socket to remove the pigtail connector and pop off the plastic housing that encases the speed sensor.
How do I know if my Club Car controller is bad?
X Common Symptoms of Controller FailureTop Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ... Sudden and Unexpected Slowing. ... Shuttering or Shaky Driving. ... Stalling Out and Refusing to Start. ... Surges in Speed When Driving.
How do I know if my electric golf cart solenoid is bad?
Press on the accelerator while the key is turned on and the cart is in forward.The solenoid needs to be replaced IF the voltmeter shows a full battery voltage without a click.If your voltmeter stays at 0, the problem stems from somewhere else in your cart.
What does the MCOR do on a golf cart?
Club Cars use an MCOR throttle device. This translates your foot movement at the pedal into electric impulse that the motor controller reads. MCOR stands for "Motor Controller Output Regulator".
Golf Cart
Support for gas-powered and electric golf carts, sometimes referred to as golf cars or club cars after the Club Car Golf Cart brand.
1 Answer
It sounds like it either doesn’t have the power to go up the hill or maybe the alternator is going out. This also could be a gear problem. Is it battery powered or gas?
Why does my 2013 Club Car jerk?
On a 2013 Club Car Precedent or any other model Club Car, the jerking can happen if your battery pack isn’t fully charged. One bad cell or battery can trigger the jerk. A battery load test will help you determine this. Make sure that both the battery pack and the batteries individually have a full charge.
How to fix a club car DS that jerks when taking off?
You can fix a Club Car DS that jerks when taking off by correcting the oil level. The following steps help to solve the jerking in 1988 lifted Club Car DS. Check the oil level of the golf cart and do a refill if needed. There is no need to overfill the oil. It’s enough if you fill it to just the required level.
How to check if a MCOR is faulty?
Check for a faulty MCOR by ensuring that the battery pack has a full charge, the key is in OFF position and pumping the gas pedal down completely 25 to 30 times. If it doesn’t get better, do an MCOR replacement. If the cart has high-speed gears, look out for a damaged commutator in the motor.
Why does my cart jerk?
Low battery charge. Check the overall battery pack charge and also the charge of each battery separately. Sometimes, low charge batteries can cause the cart to jerk. Charging the pack or the concerned battery/batteries to full voltage is likely to help.
What to do if golf cart has multiple limit?
If the golf cart is a speed switch/multiple limit style, check for proper engaging action of the wiper arm and contacts and take the necessary action for this to happen if they don’t.
Why does my club car DS shake?
Your Club Car DS may shake when accelerating because of an overly tight drive belt or a clutch issue. Sometimes, this problem happens when the carburetor fails to mix the fuel properly. The following tips can help to address these issues in a 1988 gas Club Car DS. Adjust the drive belt so that it can be slid off easily.
Is the Ping G25 adjustable?
Is the Ping G25 driver adjustable? The Ping G25 driver is adjustable. It’s possible to do four adjustments using the hosel adapter of the driver apart from the stated loft setting and...
Why is my club car not moving?
A Club Car golf cart can start clicking but not move, due to dust accumulating inside the battery ports. Opening the battery ports and checking whether there is any dust accumulation can tell you if this is the case. Cleaning it thoroughly with a cloth can resolve the problem.
Why won't my club car DS move?
If your club car makes a clicking sound but doesn’t move, the issue could be due to a faulty battery or damage to the internal controller. Check whether the batteries are working fine. Use a voltmeter to check the static voltage of the batteries.
Why does my motor make a clicking sound?
The clicking sound that you hear is made by the solenoid. There are many reasons why this could be happening. If the battery is down you might hear the solenoid click. If the wires between the solenoid and the motor are not connected properly, the solenoid might make this sound. If the motor or the controller is damaged then again, ...
What does it mean when your club car battery is too low?
If the voltage is too high or too low, it means that the battery needs to be recharged fully. Try recharging the battery to its full capacity. If the voltage still keeps fluctuating, you may have to replace the battery. Check for a similar brand and model suitable for your club car.
Can a car controller be defunct?
In most cases, the controller could have become defunct after many years of use. You can take out the controller and test it to see if it is working correctly. The resistance coil can also prevent the car from moving forward. It is often found that the resistance values are out of the normal range.
Why does my golf cart make a grinding noise?
If your golf cart is making a weird grinding noise while it is running, the issue could be due to bearings. Normally, we find that the cart makes a kind of groaning and grinding noise that can be very irritating. This is usually due to a problem with one of the physical or mechanical parts.
Where is the spacer on a car?
There is a spacer attached to the vehicle under the rear tire on the driver’s side. This can be found between the transaxle and the tire. If the spacer is loose, it could cause some grinding noise from the rear end. Check whether the axle is spinnable by hand and if so, it is indeed loose.
Is the Ping G25 adjustable?
Is the Ping G25 driver adjustable? The Ping G25 driver is adjustable. It’s possible to do four adjustments using the hosel adapter of the driver apart from the stated loft setting and...
Can a golf cart make a noise?
Golf carts can sometimes make some very weird noises. While these noises may not be particularly dangerous, they can be irritating and possible a sign of damage. If you want your golf cart to last you for many years to come, you’ll want to investigate and fix such noises. I have created this handy guide to help you troubleshoot any golf cart noises ...