It's pretty common on EZGO golf carts if the castle nut that holds the drum on isn't tight enough. Pull the center caps off of the drums and with the golf cart sitting on the ground you will see the axle spinning but the wheel isn't. Replace the brake drum and you'll be good to go.
Full Answer
Is it bad to jack up a golf cart?
While it is not harmful to the golf cart to be jacked up and will not cause any damage to the vehicle, it is not recommended to jack your golf cart up and leave it that way for long periods. It is good to jack up the golf cart only when it is time to replace the tire or work on the vehicle.
Why does my golf cart keep running but not shut off?
1994 Club Car golf cart keeps running This kind of problem with shutting down can occur in both gas and electric golf carts. There are different reasons why it can happen; some of them are discussed below: May be the starter is still operating because the spring, which pulls back the pinion to the rest pose, is not doing its job correctly.
Why does my golf cart Jerk when I drive?
If your golf cart is jerking, it’s most likely the battery. However, if you’ve ruled that out and are still experiencing this problem, there may be other issues to consider. Check the connections, solenoid, speed controller, and alignment of the cart.
How do you troubleshoot a golf cart?
On gasoline carts, check the battery that turns the engine over to make sure it is charged. On Electric carts, the battery pack should be checked for a full charge. If there is no click when the pedal is pushed, then there is no solenoid activity. How Do You Troubleshoot a Gasoline Golf Cart? How Do You Troubleshoot An Electric Golf Cart?
What would cause an electric golf cart not to move?
Solenoid Wear When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.
How do you test a potentiometer on a golf cart?
Use an ohmmeter to test across those two wires, either at the controller or at the potentiometer. If you have a 0-5K ohms golf cart potentiometer, you would expect for the reading to be at zero and slowly progress to 5,000 ohms at pedal down position.
What causes an electric golf cart to hesitate?
In most cases, the hesitation problem occurs due to bad batteries. If you have bought new batteries for your EZGO RXV, make sure to fully charge them before the first use. Batteries should then be charged after every use. To keep the batteries in check, get a Digital MultiMeter to measure the individual voltage.
Why is my golf cart not firing?
First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.
How do I know if my club car controller is bad?
X Common Symptoms of Controller FailureTop Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ... Sudden and Unexpected Slowing. ... Shuttering or Shaky Driving. ... Stalling Out and Refusing to Start. ... Surges in Speed When Driving.
Where is the reset button on golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do I know if my electric golf cart solenoid is bad?
Press on the accelerator while the key is turned on and the cart is in forward.The solenoid needs to be replaced IF the voltmeter shows a full battery voltage without a click.If your voltmeter stays at 0, the problem stems from somewhere else in your cart.
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
Why does my electric golf cart go slow uphill?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart's slow speed.
Why does my EZGO gas golf cart not move?
The main reason why a EZGO gas golf cart will not go forward is because of a locked up brake, or a faulty solenoid and accelerator. A defective Run/Tow or Forward/Reverse switch can also cause a EZGO to not move forward.
How do you test a golf cart coil?
Take the voltmeter's black and red probe and place it on the –ve and +ve terminal of the coil. Take the readings. It should be between 3.7-5.2 ohms. If outside the range, the coil should be replaced.
Can you flood a gas golf cart?
Dirt accumulation in the fuel has been seen to be one of the most frequent causes of flooding in the golf cart. This is because the valve seat may not have sealed correctly in order to shut off the fuel. Dirt inside your EZGO fuel can cause the the valve to malfunction, resulting in flooding.
When do golf carts need to be jacked up?
A golf cart needs to be jacked up at times when the tires need replacing or if there is a flat tire.
How to jack up a golf cart?
The steps to jack up a golf cart safely are: Locate the jack points. Engage the parking brake. Turn the power off on your golf car. Choke the rear wheels. Locate the frame rail underneath the golf cart. Place the jack in the jackpoints. Carefully lift up the golf cart. Slowly lower the jack.
Why do you need a chock on your golf cart?
A chock will help to keep everything stable when lifting your golf cart.
Why do you need to engage the parking brake when jacking up a golf cart?
It should be engaged before jacking up a golf cart because it will help prevent the rolling of the vehicle during the lifting process and keep wheels from spinning while being lifted off the ground.
What is the difference between a golf cart and a jack?
The difference between jacking up a vehicle and lifting a golf cart is that when you jack up a vehicle, the tires are off the ground. When lifting, it is usually lifting just one tire.
What do you need to jack up an EZGO golf cart?
In order to safely jack up your EZGO or Club Car golf cart, you’ll need a jack, jack stand and a floor mat. Jack. Jack stand to raise the vehicle off of the ground. a floor mat (optional) If you don’t have a jack, a cinderblock will work, but this is not recommended due to safety concerns. A jack stand should be used to support ...
Why do you need a jack stand?
A jack stand should be used to support and stabilize vehicles while they’re jacked up with blocks under them so that it doesn’t fall over when lifted by its wheels. A floor mat can also provide some stability if needed, but this isn’t recommended since mats may slip around too easily, causing instability during use.
What is a gas club car?
Gas club cars are mostly used for maneuvering rolling hills, rougher terrain, and for transportation of heavy payloads. Here I have mentioned a few troubleshooting steps which can help to shut off your car, and also, they are necessary when you are using the vehicle regularly.
How to turn off a car with a key?
Switch off the car with your key. Set forward or reverse to neutral. Now find out the run or tow switch and put it to tow. If the negative battery terminal is connected to the battery pack, disconnect it. Now put the switch from tow to run and the forward or reverse switch to reverse. Then turn the key switch on.
Can you fix a 2003 club car golf cart?
There are a few things you need to do to fix the shutdown issue of the 2003 club car golf cart. If your car is new and still facing such problems, then do not worry. It’s just a matter of minutes, as there will be no bigger issues. They can be fixed easily.
Can you fix a faulty solenoid?
You cannot fix the solenoid; in case of the faulty solenoids, replacement is the only option.
Why does my golf cart not click?
This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid.
How to tell if a golf cart won't start?
The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops ...
How to tell if a golf cart is bad?
Symptoms Of A Bad Solenoid 1 The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. 2 The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops and will result in destroying the starter, the wiring, or the flywheel. 3 The relay clicks and works sometimes, and sometimes it doesn’t. This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. 4 The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid. 5 The golf cart solenoid clicks, but nothing happens. This will sometimes be the result of burned contacts or contacts no longer coming in contact with each other as shown in the illustration at the bottom of this page. This can also be the result of not enough voltage amps reaching the solenoid control connection due to a low battery.
What causes a car to start when the spark plug is replaced?
If it sputters and tries to start, then the likely culprit is the fuel pump followed by the carburetor. The fuel pump on most gasoline powered carts usually has three hoses going to it.
How to tell if a battery is leaking?
It can begin with the batteries taking longer and longer to charge, and the charge they take, they don’t keep very long. Physical signs can include bulging sides, cracks or, in extreme cases, leaking battery acid. If the engine or motor turns over slowly, get out a multimeter and make this quick test.
How to check if a gas cart battery is charged?
First, you turn the key, press the pedal, and listen for a click. If nothing happens, it’s most likely an electrical issue. On gasoline carts, check the battery that turns the engine over to make sure it is charged. On Electric carts, the battery pack should be checked for a full charge.
What to do if a gas cart key switch fails?
There should be a reading or continuity between any combination. If this is a gasoline cart, set the switch to “ON” and take a reading between the terminals. There should be continuity. If the key switch fails any of these tests, it’s worn out and should be replaced.