An EZGO golf cart goes fast in reverse if the wires on the motor are swapped, the Forward/Reverse switch is not in sync with the direction of the cart, or if there is a short of two wires at the motor or the Forward/Reverse switch. You can try the following suggestions mentioned here.
Full Answer
Why won’t my gas golf cart work in forward or reverse?
A surprisingly common problem with gas-powered golf carts is that they fail to work in forward or reverse. Why Won’t My Gas Golf Cart Work in Forward or Reverse? Most of the time golf carts won’t work in forward or reverse due to the shift cable being broken, electrical issues, ignition switch issues, or a too low idle speed.
How do I switch between forward and reverse on a golf cart?
Golf carts have a button or lever that allows you to switch between forward and reverse gears. The reverse switch is found below the driver’s seat, and can be activated by pulling the handle left or right.
Why is my EZGO RXV golf cart stalling?
EZGO RXV carts tend to stall if the battery pack voltage is low. Look at all the battery connections and ensure that all of them are tight and free of corrosion. Tighten loose ones and clean or replace the corroded connections. This happens often in 2009 EZGO RXV golf carts. Watch out for any discoloration in the solenoid.
Are there any electrical problems with a gas golf cart?
While you might own a gas golf cart, there are still a number of electrical components that can malfunction. Here are a few of the main electrical problems that can occur with your gas golf cart. The ignition switch on your cart is known to have problems. Wires can become loose, or ground out which causes your golf cart to not fully operate.
What controls the speed on a gas golf cart?
The controller meters out current and voltage on your battery based on user input, whether that be a gas pedal, a throttle, or even pedals on a bicycle. With the controller you are able to control your acceleration and deceleration, as well as the speed at which your vehicle moves.
How do you slow down a gas golf cart?
0:273:57How to Adjust Governor on Yamaha G29 Drive Gas Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo on your car you take the rear inspection panel off right underneath it here. You will have aMoreSo on your car you take the rear inspection panel off right underneath it here. You will have a spring actuated governor this is actually what speeds you up and slows you down.
Why does my golf cart go slow in forward?
Low Battery Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
How do you adjust the speed on a gas club golf cart?
0:131:31Club Car Precedent Speed Increase SUPER EASY!!! - YouTubeYouTubeStart of suggested clipEnd of suggested clipIf you turn it that way to the right or what appears to be counterclockwise. It slows it down. AndMoreIf you turn it that way to the right or what appears to be counterclockwise. It slows it down. And if you turn it that way or clockwise it speeds things up. Very.
How do you adjust the governor on a Club Car gas golf cart?
0:040:46How to remove governor on a Club Car golf cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou open up this box lap. Here. It looks up look inside. There's 12 cable down right here this leverMoreYou open up this box lap. Here. It looks up look inside. There's 12 cable down right here this lever you want to lift up and Bend and that pulls on the cable a little more.
How do you adjust the carburetor on a golf cart?
Find the pilot adjustment screw on the edge of your carburetor. Pay attention to this screw – it should be a sharp point and not flat. Carefully remove this screw and then carefully screw it back. Turn this screw out one and one-half turns to adjust it properly.
Where is the speed sensor located on a golf cart?
The speed sensor in a Club Car Precedent golf cart is located on the back of the motor. To remove the sensor, unplug the cables behind the motor. You can use a 5/16-inch socket to remove the pigtail connector and pop off the plastic housing that encases the speed sensor.
Why does my gas golf cart go slow uphill?
A fully charged battery can create up to 24 volts. With a voltmeter, determine how much current you need by checking if your cart will move on flat ground with a dead battery. If your golf cart's speed drops significantly as it ascends an incline, your batteries may be weak and need replacement.
Why is my gas golf cart losing power?
A faulty or broken carburetor is likely the most common triggering factor for serious issues with your cart's power problems. The carburetor helps to keep your cart cleaner in operation and manages many elements of your fuel in your cart.
How do you adjust a speed controller on a golf cart?
Basically, an electric speed governor can be controlled by a tiny metal rod that's located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by rotating the nut in a counterclockwise rotation.
Where is the governor on a gas golf cart?
0:061:28Where Is a Golf Cart Governor Located? - YouTubeYouTubeStart of suggested clipEnd of suggested clipWell a golf cart's governor located is actually down in the motor. Compartment. Some of them theseMoreWell a golf cart's governor located is actually down in the motor. Compartment. Some of them these electric ones nowadays. Actually the governor isn't a true governor. It is a control speed.
How do you soop a gas golf cart?
Your cart will thank you in the long-run.Upgrade Your Golf Cart Motor.Improve Golf Cart's High-Speed Controller / Solenoid Contactor Relay.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Keep Your Cart Light / Keep It Clean.
golfcartman
When you removed the batteries, a certain procedure MUST be followed. Key switch off, switch to tow position and shift lever in reverse. You must wait until the beeper unit sound dies out then remove the wire from the most NEGATIVE cable. Place in Neutral before installing new batteries.
golfcartman
Your batteries have died. The reason it will barely move in reverse is that current is being supplied to the motor is a direction that it spends very little time using. There is a slight change in the armature over time, and reverse tends to work better over time. Check the voltage when under load.
Why won't my golf cart move?
Loose or corroded cable connections or a faulty controller can also cause the golf cart to not move. Malfunctioning microswitch. Faulty solenoid. Defective ignition switch. Loose or corroded cable connections. Faulty controller.
What happens if your golf cart battery doesn't charge?
Look out for a closed pedal switch that could be restricting the movement of the golf cart. When this is released, the cart will start moving properly .
Why won't my EZGO go forward?
The main reason why a EZGO gas golf cart will not go forward is because of a locked up brake, or a faulty solenoid and accelerator. A defective Run/Tow or Forward/Reverse switch can also cause a EZGO to not move forward. You can check out the steps given below to address this problem. Check if the brakes are performing as desired ...
What happens if a golf cart solenoid is defective?
When defective, the solenoid fails to transfer current from the battery to other parts of your golf cart.
How to check if ignition switch is working?
You can do this by hooking the wires present under the dash, connecting it to the battery, an ohmmeter, and check the reading. If you don’t get any reading, change the switch.
Is the Ping G25 adjustable?
Is the Ping G25 driver adjustable? The Ping G25 driver is adjustable. It’s possible to do four adjustments using the hosel adapter of the driver apart from the stated loft setting and...
1. Speed Sensor Issues
The speed sensor is an essential and critical part of golf cart operation that helps to ensure that cart runs smoothly and efficiently. It operates by measuring how fast you are driving and how much electricity is needed to maintain that speed. When the speed sensor ends up running into trouble, chances are your cart may end up running slowly.
2. Low Battery
Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
4. Bearing Encoder Issues
The bearing encoder is an essential part of your golf cart that provides you with careful electrical charge distribution throughout your cart. It works by encoding various elements of your cart's operation and translating them to different impulses to keep the power running smoothly.
5 Ampacity Controller Fault
The Ampacity controller is a part of your cart that helps to manage the amperage that produces and uses as your cart drives. When this particular part malfunctions, you're going to run into some issues with your cart operation.
How to Increase your golf cart speed?
Are you looking to increase your golf cart speed? Learn more about how to make your golf cart go faster.
