Full Answer
Why won’t my golf cart charge?
Check if the charger is not plugged into the receptacle of the golf cart. The charger needs to connect with sockets within the replaceable. Examine the charger’s cable connections. Damaged cables will not be able to charge the batteries. Using an extension cord is not ideal for charging a golf cart.
What should I do if my golf cart wont start?
If your golf cart won't start, the first thing we suggest it checking your battery! Electric golf cart batteries need to be charged and have water added regularly. If you purchase a preowned electric golf cart, be sure to ask about the age of the battery before you buy.
Why won't my electric golf cart go uphill?
My electric golf cart will not go uphill and losses power quickly. When golf cart gets just slightly below a full charge it will not go uphill. It will go on flat land. Battery voltage was a little low but batteries still tested good. Answered! View the answer I have this problem too
Can you make a golf cart run after driving for some time?
One of the most common complaints with golf carts is that it dies after driving for some time. Have you ever experienced this? You may have tried to make it run by getting the choke on. The cart will generally oblige and run for a few minutes before shutting off again.
What would cause an electric golf cart not to run?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won't start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
Why will my electric golf cart not power up after a charge?
If your batteries aren't hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
Why does my golf cart keep shutting off?
Why Does My Golf Cart Keep Shutting Off? When a Golf Car is shutting off without warning, it's because of low battery voltage, dead batteries, or because the solenoid coil is overheating. Low battery voltage: Sometimes a dip in the minimum voltages of both batteries causes the Golf Cart to turn off randomly.
Where is the reset button on a golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do I reset my club battery charger?
How to reset your Club Car's OBC after a faultKey Switch to Off.Forward/Reverse to Neutral.Tow/Run Switch to Tow.Disconnect the Battery NEGATIVE (–) wire from the Battery Minus terminal on the battery pack.Put the Tow/Run to Run.Forward/Reverse Switch to Reverse.Key Switch to On.Lock the throttle pedal down.
What happens when golf cart solenoid goes bad?
What Happens To Your Golf Cart When The Solenoid Goes Bad? The large contacts in a gas golf cart may refuse to release, causing the starter to run even after turning off the ignition.
What causes a golf cart to stall?
The most common reason why your golf cart is stalling is due to a bad solenoid or a faulty speed controller. What is this? The solenoid wears out every time the gas pedal is pressed down. The solenoid gets pressed down to a thin plate.
Do all electric golf cart motors have a reset button?
Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state. While it doesn't repair damage that may have occurred to the motor over the years, obviously, it does help to overturn any changes to the operation which may have occurred.
How do you troubleshoot an electric golf cart?
There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.Test the wall socket where you charge your cart. ... Expose your golf cart batteries. ... Test the batteries for voltage. ... Replace dead batteries. ... Expose the motor for inspection. ... Reset the motor. ... Test the cart.
How do I reset my golf cart?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
Find A New Golf Cart Battery Charger Or Batteries
1. All Golf Cart Chargers 2. Club Car Chargers 3. EZGO Chargers 4. Yamaha Chargers 5. Buyer's Guide - Picking the Best Golf Cart Charger. 6. Golf C...
Troubleshoot An Old Golf Cart Battery Charger & Batteries
1. Why is my golf cart battery charger not working? 2. I manually charged my batteries, that did not work, now what? 3. Do I have a battery or a ch...
Golf Cart Charger Questions
1. How do I choose a replacement charger for my Powerdrive, Powerwise, etc.? 2. What's the difference between the Links & Summit charger? 3. How lo...
Golf Cart Battery Questions
1. Do I have 6v, 8v or 12v golf cart batteries? 2. Do I have a 36 volt or 48 volt golf cart? 3. How long do golf cart batteries last? 4. How can I...
Why is my golf cart not charging?
If your batteries are carrying a minimal load, and your charger will still not charge them, it may be because your golf cart’s onboard computer is confused about how much charge they are currently carrying.
How to troubleshoot a golf cart battery charger?
If your batteries get too low, you could be stranded. To avoid this, you have to ensure that your battery charger is working correctly. If your battery charger ever fails, ...
Why does my charger fail?
If your batteries aren’t hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
How many volts does a battery charger need to charge?
When your charger can’t tell that your batteries are hooked up, it often won’t even turn on. A base charge of 25-30 volts is usually sufficient to wake up your charger and begin charging. To get around this problem, specific chargers offer modes that keep your batteries charged even when you’re not using them.
What to do if battery charger fails?
You can’t address every problem with a simple DIY repair, but a sound diagnosis can save hours of frustration. In many cases, the solution is simple, and you’ll be able to handle it with minimal expense.
Why won't my battery turn on?
Make Sure the Batteries have Some Charge. In the scenario that it doesn’t turn on, it might mean you waited too long to recharge them, and now the charge that they currently carry is too low for the charger to detect them. When your charger can’t tell that your batteries are hooked up, it often won’t even turn on.
What to do if battery is stuck at no charge?
However, if you’re stuck at no charge, a small, manual charger should provide each battery with enough juice to activate your regular charger.
Why is my golf cart battery charger not working?
Bad connections will cause any battery charger to not function properly. After you've charged up your batteries and checked every connection and you are still having issues, it's probably safe to say you've got a golf cart battery charger problem and may need to service it or buy a new one.
Why is my golf cart charging red?
Occasionally a red fault light on a golf cart charger can mean that the batteries do not have enough voltage in them to allow the charger to kick on (see Charging Dead Golf Cart Batteries above).
What is an OBC on a club car?
When you plug the charger into your Club Car, the OBC will tell the battery charger when to start and stop charging based on the voltage levels in your batteries.
What voltage do you need for a 36V golf cart?
You must match volts to volts. A 36V cart requires a 36 volt golf cart charger. A 48V cart requires a 48 volt golf cart charger. You can burn up your batteries if you do not charge with the proper voltage.
How many volts does a golf cart battery need?
An automatic golf cart battery charger needs a minimal amount of voltage in the golf cart battery to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.
Why is my charger making a clicking noise?
If the charger makes a loud clicking noise, this is likely a battery charger issue.
How to keep a charger from getting hot?
But here are a few general tips to keep the charger from overheating: Make sure that your battery cable connections are correct, clean and tight.
Why does my golf cart not click?
This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid.
How to tell if a golf cart won't start?
The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops ...
How to tell if a golf cart is bad?
Symptoms Of A Bad Solenoid 1 The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. 2 The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops and will result in destroying the starter, the wiring, or the flywheel. 3 The relay clicks and works sometimes, and sometimes it doesn’t. This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. 4 The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid. 5 The golf cart solenoid clicks, but nothing happens. This will sometimes be the result of burned contacts or contacts no longer coming in contact with each other as shown in the illustration at the bottom of this page. This can also be the result of not enough voltage amps reaching the solenoid control connection due to a low battery.
What causes a car to start when the spark plug is replaced?
If it sputters and tries to start, then the likely culprit is the fuel pump followed by the carburetor. The fuel pump on most gasoline powered carts usually has three hoses going to it.
How to tell if a battery is leaking?
It can begin with the batteries taking longer and longer to charge, and the charge they take, they don’t keep very long. Physical signs can include bulging sides, cracks or, in extreme cases, leaking battery acid. If the engine or motor turns over slowly, get out a multimeter and make this quick test.
How to check if a gas cart battery is charged?
First, you turn the key, press the pedal, and listen for a click. If nothing happens, it’s most likely an electrical issue. On gasoline carts, check the battery that turns the engine over to make sure it is charged. On Electric carts, the battery pack should be checked for a full charge.
What to do if a gas cart key switch fails?
There should be a reading or continuity between any combination. If this is a gasoline cart, set the switch to “ON” and take a reading between the terminals. There should be continuity. If the key switch fails any of these tests, it’s worn out and should be replaced.
Why won't my club car golf cart turn off?
A Club Car golf cart will not shut off if the OBC is outdated or faulty. In this case, the reason depends on whether the charger is not shutting off when it is plugged into the device , or it is not plugged in but still not shutting off.
Why is my club car not charging?
The cause of a Club Car golf not charging is either a dead battery, a damaged power cable, or a faulty charger.
Why is my charger clicking?
If the charger is clicking while plugging it in, and doing nothing, examine your charger and probably replace it . If the “brain” of the charger fails , then it can cause several issues, and the batteries will not charge. Purchasing a new one or repairing the component can solve the problem.
What is the OBC on a 48V club car?
In the 48V club cars, the OBC is primarily responsible for the batteries’ charge. It controls the batteries charging, which is why the 48V requires a fully functional OBC all the time. Connect the batteries to a voltmeter and check if the charger is generating enough power.
What happens if your golf cart battery is low?
If the water level of the batteries is low, then the blade inside it will be dried, and you won’t be able to recharge your battery. Charging problems of golf carts are not something new. It can be quickly resolved. All you need to do is to examine the cart thoroughly and immediately replace the faulty parts.
How to keep car batteries charged when idle?
Try to keep specific chargers, which will help your batteries to stay charged even when the car is idle. Enough power supply is critical to keep the charger working and keep the batteries charging. Check your connections, and then turn on your charger.
What does it mean when a charger is bad?
Bad charger: if the charger turns on but there is no sign of charging. If the charger is making noises like a loud click, before kicking off. If the charger keeps charging even after turning the switch off then, without any doubt, it’s time to replace the charger.
Why won't my electric golf cart start?
Today, we'll look at the most common problems with electric golf carts, and how you can prevent or repair them. 1. Batteries That Break Down or Lose Charge. If your golf cart won't start, the first thing we suggest it checking your battery! Electric golf cart batteries need to be charged and have water added regularly.
Why is my golf cart ignition not working?
If your ignition has problems, it's almost certainly due to wear and tear or the age of your golf cart. Wires can become loose and lose the connection between the switch and the battery, or they may require replacement when they wear out or break over time.
What is the solenoid on a golf cart?
The solenoid is a cylindrical coil of wire that works as the magnet carrying an electric current. Basically, when you start up your golf cart, the solenoid is the reason for the clicking sound you hear when engaging the acceleration pedal. This sound is a good thing!
What is a direction switch on a golf cart?
Direction Switch. The direction switch simply lets you control whether your golf cart is in forward or reverse. One of the most frequently used parts on a golf cart, it's heavily prone to wear and tear and breaking down over time.
Do electric golf carts run quietly?
They generally run more quietly than gasoline-powered golf carts and ATVs do, and keeping them moving is as simple as keeping up with preventative maintenance and maintaining a full charge. However, electric golf carts do have their share of unique concerns and potential issues that you'll want to keep an eye out for.
Do you need to replace a golf cart battery?
If you purchase a preowned electric golf cart, be sure to ask about the age of the battery before you buy. You may not need to replace your battery for a long time, but the older a golf cart is, the more prone it may be to corrosion.
Can you turn off the radio on a golf cart?
Any lights, radio, or electric components in your cart should always be turned off when you stop using it. Leaving the radio or lights running on an idle golf cart can run down the battery incredibly quickly. In the case of a gasoline-powered golf cart, you may end up having to jump-start the cart to get it working again if this happens.
Can you use an automatic battery charger when it is fully charged?
It's important to make sure you're using an automatic battery charger that will stop being active as soon as the battery is fully charged. We've had clients come in with what they felt were "bad" batteries, only to have to explain to them that the battery had simply been damaged by being overcharged too many times.
Can you drive a golf cart up steep hills?
Forcing your golf cart up very steep hills or to go longer distances than it is made for will run the battery down and could leave you stranded. Just keep a careful eye on distance traveled and consider using a truck or trailer when transporting your golf cart longer distances.
Should golf cart batteries be charged?
Another common issue is golf cart owners who think that golf cart batteries should only be charged when they've become very low. If you drive your golf cart that day? Charge the battery. Letting golf cart batteries run down until near-empty or totally dead will damage them over time just as much as overcharging them.
