Why is my Yamaha golf cart smoking?
A Yamaha golf cart may be smoking because the exhaust is plugged with burnt oil that causes back pressure. If it’s blowing the oil fill cap off, then oil is clogged up and causing pressure in the crankcase.
Why is my club car golf cart burning oil?
A club car golf cart with a blown head gasket is the most common cause of the golf cart burning a lot of oil. The presence of accumulated dirt inside the gasket can also cause oil to burn. When a club car golf cart burns excess oil, your fuel expenditure shoots up drastically.
Why is my Yamaha G9 burning oil?
Your Yamaha G9 is burning oil because it’s been lifted and you’ve incorrectly overfilled its oil. Lifting your cart tilts the cart engine and makes your oil dipstick reading wrong. Fix this by draining the old oil and refilling the engine with exactly one quart of oil. Then take the oil dipstick and mark the new, correct “full” position.
Why is there oil in the airbox of my Yamaha golf cart?
If that’s the case then you need to rebuild your engine to replace the rings and fix the problem. Why is there oil in the airbox of your Yamaha golf cart? There’s oil in your airbox because there’s too much oil in your engine. If there’s too much oil, it’s probably because of a mismarked dipstick in your engine.
What causes a golf cart to burn oil?
A club car golf cart with a blown head gasket is the most common cause of the golf cart burning a lot of oil. The presence of accumulated dirt inside the gasket can also cause oil to burn. When a club car golf cart burns excess oil, your fuel expenditure shoots up drastically.
Can a golf cart overheat?
Motor burnout happens when your engine gets too hot and overheats, frying the wiring and other components inside. One common cause of golf cart motor burnout is continually pressing the pedal to the metal like you're trying to drive a race car.
How do I know if my golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How long do golf cart motors last?
Golf Cart Motor Just like solenoids (mentioned above), your golf cart motor works HARD. When properly taken care of, the typical gas or electric golf cart motor can last many, many years (20 to 30+).
How do I fix my smoking golf cart?
Remove the valve with gloved hands to avoid getting stained by excessive grease or oil. Clean off the area where you are installing the valve and put the new valve in place. Tighten it down and your engine should stop smoking. If the clog is deeper in your engine or beyond the valve, you are going to need expert help.
Why is my cart overheating?
Carts get hot because electricity travels through the coil, turning your oil into vapor.
How do I reset my Yamaha golf cart?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.
What are the symptoms of a bad solenoid in a golf cart?
If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.
Why does my golf cart slow down going downhill?
Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart's slow speed.
How long will a Yamaha golf cart last?
With all other brands-EZ Go, Yamaha, etc... They make them with steel frames and they will rust and eventually break. Longevity ranges between 30-40 years or longer for the various manufacturers.
Is Yamaha or ezgo better?
Which is better EZGO or Yamaha Golf Cart? A Yamaha golf cart is a better option over an EZGO golf cart as it is more power-efficient and has lower maintenance costs. Yamaha carts are more economical than EZGO because they have no fuel pumps and filters to refill or replace.
How fast does a Yamaha golf cart go?
Most electric golf carts are faster than gasoline golf carts. Although, new gasoline and electric golf cart versions of Yamaha all have the same top speed. The top speed of both versions of Yamaha golf carts is 19 mph (31 kph).
What happens if a golf cart burns oil?
When a club car golf cart burns excess oil, your fuel expenditure shoots up drastically. Apart from that, it could result in several other issues that would have an impact on the durability of the vehicle in the long run. An experienced golf cart user will know when there is excessive fuel consumption and the steps to be taken to correct ...
Why does my club car burn oil?
A club car could burn oil because of multiple reasons. Some of the most common causes of a club car burning oil are: Presence of gas. The piston rings positioned in front of the cylinder walls act as seals and do not let any gasoline get into the oil.
How to fix club car oil?
There are a couple of effective ways to fix a club car that’s burning oil. Check compression. You can check the compression of your club car cylinders using a compression gauge. You have to take into account the PSI reading for every cylinder.
What is the purpose of piston rings?
Their main function is to ensure that the engine oil remains in the crankcase and there is a good balance between the air and fuel mixture in the engine.
What does it mean when a 1996 club car burns oil?
1996 Club Car is Burning Oil. The first step is to do a compression test. If you see black smoke, you must know that the vehicle is burning excessive oil. Since the vehicle is old, there is a chance of the engine malfunctioning. Replacing the motor could help to get rid of this problem.
How to fix 1993 Club Car oil burn?
When your 1993 Club Car is burning excessive oil, you can try draining out all the oil, get the filter replaced and clean the carburetor thoroughly. After completing this process, start the engine again and check if it is still burning oil.
What to do if you have white oil in your car?
One of the most basic things you need to do is to check the fuel pressure regulator. You have to detach the vacuum line from the regulator and verify if any fuel is present in it.
How long does it take to change the oil on a golf cart?
If you are a regular cart user, 150-250 hours of operation should take around 6 months. The timeframe for changing the oil in any golf cart depends on the time for which the cart is operated. If you can’t keep a track of your cart’s running hours, you can always turn to the dipstick oil level indicator.
How to check oil level on a cart?
With the cart on a level surface and engine a little warm, take the dipstick out. Clean it with a dry piece of cloth and dip it in to check the oil level. If the oil level is below the safe range, operating the cart without an oil change can leave the engine damaged.
How much oil does a Yamaha G16 hold?
The oil capacity of Yamaha G16 is lower than the Yamaha G2 and it can hold only around 1.16 US qt. The type of oil to be used remains the same; 10W-30 non-synthetic.
Where is the drain plug on a Yamaha G16?
The drain plug is right under the driver seat in the Yamaha G16 cart. You can un-screw that using a 17mm drain bolt. Once the engine oil is completely drained out, screw the drain plug back in its position. Open the oil filler cap on the top side of the engine.
Is it bad to run an engine without oil?
It is important to ensure that the engine oil is not overfilled. Overfilled engine oil can disrupt the flow of oil causing severe damage to the engine. It is as harmful as an engine running without engine oil. Often the crankshaft comes in contact with the oil adding air in the oil flow system.
Can you use synthetic oil on a Yamaha golf cart?
The synthetic oil can prove to be too thin for Yamaha’s splash system mechanism. There are several synthetic oil options available in the market with the YamaLube being the most popular for Yamaha golf carts. Mobil 1 non-synthetic oils can also be used and are quite good with golf cart engines.
Why is my Yamaha golf cart overheating?
One of the most common reasons for the overheating is the dirty fins. The obstruction in the fins leads to excessive heat.
What temperature should a Yamaha golf cart be?
Generally, a temperature of 170ºF is considered reasonably safe for your Yamaha golf cart motor. If the temperature exceeds 250ºF this indicates a serious problem. In simpler terms, if you can touch and hold your cart motor for 5 secs without burning your fingers then there is no reason to worry.
Why should the tank vent be open?
The tank vent should always be open to allow air circulation , that acts as a cooler to prevent your engine from fuming. Sometimes the vent is too tight and needs more pressure to open. This leads to overheating till the vent is opened. Dirt and mouse nests are common on the fins and under the shroud.
Why is my G9 overheating?
Clogged muffler. If the overheating in your G9 is accompanied by noise, then it could be due to a clogged muffler. Try to clear the vent using a water gun while the engine is not running. This is likely to solve your problem.
Why is my cart shutting down?
If your cart is shutting down midway, then it could be due to overheating. With excessive heat, the controller may also get heated leading to the cart giving up on you. Loud Exhaust. If your exhaust is suddenly making more noise than usual, then that could also be an after-effect of an overheated engine.
Why does my car overheat?
Another common reason for the engine overheating can be the faulty bearings. If the bearings are faulty or loose and rubbing against other parts, then that can lead to excessive friction and heat. This may need a professional to check and assess the extent of the damage.
Does a cart have a cooling mechanism?
Every cart comes with its cooling mechanism. Yes, the coolant. Make sure you have enough liquid to keep your engine cool. Make it habit to check the liquid levels regularly. Tighten the loose Connections. Sometimes, loosely wound wires and improper connections can also be the reason for overheating.
Why won't my Yamaha golf cart go uphill?
Your Yamaha golf cart will not have power while going uphill if it has a fuel related problem, a worn-out, cracked, or loose drive belt or tension cable, malfunctioning clutches, or low battery voltage.
Why does my Yamaha golf cart have no power?
A Yamaha electric golf cart usually has no power on its solenoid due to a faulty controller, cut wires, or blown-out fuses. Remove the small black wire connected to the solenoid and check if the voltage of its small red wire connection rises to the battery pack voltage. If yes, you have to do a controller replacement.
Why is my Yamaha G16 losing power?
Your Yamaha G16 could be losing power because of a malfunctioning secondary clutch, a broken secondary spring, a worn-out drive belt, or bad fuel. Sometimes, loose wire connections or cable ends, dirty air and fuel filters, a faulty spark plug, or an improper valve adjustment may trigger the problem.
How to check if golf cart is running out of power?
Do a compression test on the golf cart using a compression tester. Low compression can also cause the golf cart to run out of power. Also, check the fuel pressure and ensure that it’s as desired. Check the clutch to see if it’s functioning properly. It should shift out when the cart is on jacks.
Why is my Yamaha G1 golf cart not turning on?
Your Yamaha G1 golf cart may have no power because of cracked seals, a plugged muffler, a fouled spark plug, or low compression. A malfunctioning clutch, an improperly adjusted carburetor, or a worn-out drive belt can also cause this problem.
What to do if a cylinder is not working?
Check the cylinder to see if compression is taking place as desired and note the timing. If it is not working as desired, you may have to change the cylinder.
Where is the fuel filter on a golf cart?
Check if the fuel filter of your golf cart is damaged and do a replacement if necessary. This filter is usually located in the fuel tank of the cart. If it’s not damaged, this is a good chance to get it cleaned.
How to find out if your cart has a burnt out motor?
First, you’ll want to reset your motor. Get out your handy screw driver and work to uncover the motor itself. It should have a small reset button (Usually it will be red) located near the main battery supply.
Why does my golf cart quit?
motor burnt-out. One of the big reasons your golf cart could quit on you is that your motor burnt out. Motor burnout happens when your engine gets too hot and overheats, frying the wiring and other components inside. One common cause of golf cart motor burnout is continually pressing the pedal to the metal like you’re trying to drive a race car.
Why won't my cart start up after resetting the motor?
However, if your cart doesn’t start up after resetting the motor, you are most likely dealing with burnout. If this seems to be the case, remove the motor from your cart and inspect it to see if there are individual parts like bearings, coils, or brushes that are just broken. You can purchase these parts for a pretty low cost ...
Where is the reset button on a cart?
It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you’re in luck!
