Do it yourself golf cart repair?
Replacing Golf Grips
- Secure the club shaft in the D-Vise, which is padded and will protect your club shaft from being marred.
- Cut off old grips with the #409 Cut-off Wheel. Be careful that you don't cut into the actual shaft. ...
- Clean off remains of old tape. ...
- After removing backing from tape, hold the new grip open-end with a finger covering the hole at the opposite end. ...
How to maintain your golf cart?
The best ways are:
- Keep batteries charged regularly and cleaned.
- Keep tires filled.
- Always look out for oil leaks.
- Check out the brakes and make sure they are well-maintained.
- Have the cart serviced regularly.
- Get any issues or suspected problems checked out by a professional.
Why is my club car golf cart not charging?
Other Common Reasons Causing Club Car Charging Problem
- Faulty transformers
- Damaged Fuses
- Failed voltage regulator
How to fix a golf cart?
- Leaf springs and shock absorbers: they dampen impact and provide support for the rest of the suspension system. ...
- Axles: also carry golf cart weight via axle bearings. ...
- Ball joints: also part of the steering system, these are pivot points between the wheels and suspension, each also supporting the golf cart’s weight. ...

Why won't my golf cart go forward or backwards?
The problem could be with either the Run/Tow switch or Forward/Reverse switch or both. Check the switches to ensure that they aren't stuck midway. If they are, getting them released should help. However, if they show signs of wear and tear, you must get them replaced.
Where is the reset button on a Club Car golf cart?
It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again.
How do you fix a golf cart that won't move?
When the cart won't move, you have to be sure that the batteries are sending sufficient power to the circuit. You must check the fuse. Use the voltmeter to check the voltage at the key switch. In a cart with batteries rated at 48V, it must show 48V at the key switch.
How do you fix a golf cart that won't charge?
1:103:54Golf Cart Charger Troubleshooting Guide | ASK DAVE | Golf Cart GarageYouTubeStart of suggested clipEnd of suggested clipTest good first off the most common issue when a charger doesn't engage is dead batteries golf cartMoreTest good first off the most common issue when a charger doesn't engage is dead batteries golf cart chargers start automatically by receiving voltage from your cart.
How do you know if your club car motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do you reset a club car on a board computer?
Resetting the OBC must be performed in this order:Key switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
Why does my golf cart click but not move?
A Club Car golf cart can start clicking but not move, due to dust accumulating inside the battery ports. Opening the battery ports and checking whether there is any dust accumulation can tell you if this is the case. Cleaning it thoroughly with a cloth can resolve the problem.
What would cause a golf cart not to run?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won't start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
Why does my gas golf cart not move?
Battery Problems Next, if your cart will start but won't move, you may have a problem with your battery. Now, a gasoline golf cart isn't as reliant on a battery for power as an electric model – which have multiple batteries that provide all their power – but they cannot run without a well-charged battery.
Why will my Club Car golf cart not charge?
The cause of a Club Car golf not charging is either a dead battery, a damaged power cable, or a faulty charger.
How do you trick a golf cart charger to charge a dead battery?
1:233:46Reviving Dead 6v & 8v Golf Cart Batteries FAQ - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since thisMoreSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since this is this negative we make this battery six volt I jump to the corresponding.
How do you know if your golf cart charger is bad?
Bad Charger: IN GENERAL, if the charger kicks on, but doesn't charge fully or kicks off soon after, this is likely a charger issue. If the charger makes a loud clicking noise, this is likely a battery charger issue.
Securing a stable connection
A faulty circuit will never establish a secure connection. Ensuring a stable connection means setting the circuit in the correct order.
Finding out the blown-out fuse
Locating the fuse box can be intimidating if you don’t know where to find it. Let us start with the Club Car-
Fixing the faulty fuse
This is our final task that should fix the headlight problem. Now that we have located our fuse-box, it is the time to get into the work-
Some specific reasons to prevent fuse-damage
An older cart is more prone to fuel damage. Besides, a faulty electrical system can always make the cart vulnerable to damages. Here are some of the specific reasons that can cause fuse damage. Do check them frequently to ensure a safe connection-
Why is it important to maintain a golf cart?
Hygiene and maintenance of your golf cart are not only important for your comfort but also the regular functioning of your golf cart. The clutch is the component of your golf cart used very frequently and can be easily soiled with dirt and dust particles.
What tools do you need to dismantle a golf cart battery?
This battery consists of various cables and wires, which are crucial for the working of your vehicle. Cutters, crimpers, nails, and a screwdriver are all essential tools you should carry in case you want to dismantle or recharge your golf cart’s battery.
Why does my electric golf cart jerk?
1] Water-logging in some of the components of your electric golf cart can result in jerking. Sensors and micro switches installed near the vehicle’s floor mat can malfunction due to water interference, which causes jerks when you accelerate.
How much does a DS golf cart weigh?
The DS produces both battery and gas-powered golf carts. The electric DS weighs 498 pounds, whereas the Gas DS weighs 619 pounds. The speed ranges between 12-15 miles/hour for the gas model, whereas 12-19 miles/hour for the electric one. Jerks can occur in the DS Car for the following reasons.
How fast is a club car?
Club Car’s gasoline-powered Tempo golf cart is one of the most highly coveted golf carts by golfers worldwide. Its speed ranges from12-15 miles/hour. The Tempo golf cart comes with a 5-year warranty and a dynamic engine of 3.3 horsepower.
How much does a club car precedent weigh?
It costs around 11,500 USD and has a minimum horsepower of 3.7 (2.7 kW). The Precedent weighs 1176 lbs, and its speed ranges from 8-14.8 miles/hour.
Why does my DS car jerk?
Battery damage: – Jerks can occur while accelerating in a DS model if the cart’s battery and other electrical components have been damaged . Repairing or replacing these components can lessen or nullify the problem of jerking.